04ift tomatosalsaPoster combined

Information about 04ift tomatosalsaPoster combined

Published on March 4, 2008

Author: Sudiksha

Source: authorstream.com

Content

Slide1:  Studies on safe acidification of salsa for home boiling water canning B. A. Nummer, M. Thacker, E. M. D'Sa, and E. L. Andress. Dept. of Foods & Nutrition The University of Georgia 328 Hoke Smith Annex Athens, GA 30602-4356 http://www.uga.edu/nchfp/pres_papers.html Slide2:  ABSTRACT Salsa is America's No. 1 condiment. This popularity has extended to home food preservers who want to make use of a seasonal harvest of garden-grown tomatoes and vegetables. Most salsa recipes mix low-acid foods, such as onions, green peppers, and jalapeño peppers, with acid foods, such as tomatoes. Currently the USDA and the National Center for Home Food Preservation recommends that a boiling water canning process be used only for research-tested salsa recipes that provide evidence of safe acidification to inhibit Clostridium botulinum growth. Only a few such research-tested salsa recipes are available and these must be followed with little deviation. This project sought to create and test a guideline recipe for salsa that allowed for variations in low-acid ingredients, while maintaining a safe level of acidification from tomatoes and lemon juice. Based on this research a safe recipe guideline ratio of 200 g Roma tomatoes, 200 g (onions, peppers, and dry spices), and ¼ cup (60 ml or 61g) of bottled lemon juice per pint volume was proposed. The lemon juice (60 ml) safely acidified a lab recipe (200 g Roma tomatoes, 120 g onions, 65 g green peppers, 15 g jalapeño peppers, and 5 g table salt per pint) to below pH 3.82. Salsa made from 200 g tomatoes, ¼ cup lemon juice and either all onions (200 g) or all green peppers (200 g) as the low-acid ingredient maintained a pH below 3.82. In acidification curves single low-acid salsa ingredients needed only 10 ml lemon juice per 200 g vegetable to acidify below pH 4.6. Furthermore, 60 ml lemon juice per pint safely acidified full pint volumes (263-304 g) of onions, green peppers, or jalapeños alone to below pH 3.82. Informal taste panels indicated an acceptable salsa flavor after canning using recipes within the guideline. INTRODUCTION Most tomato-based salsa recipes mix low-acid foods, such as onions, sweet and/or hot peppers, with acid foods, such as tomatoes. Currently the USDA (2) and the National Center for Home Food Preservation (http://www.homefoodpreservation.com ) recommend that a boiling water canning process be used only for research-tested salsa recipes that provide evidence of safe acidification to inhibit Clostridium botulinum growth. The USDA Complete Guide to Home Canning (2) has only one salsa recipe. Research by Hillers and Dougherty (1) created six more salsa recipes for home canning and these have been attached to the USDA Complete Guide to Home Canning by Utah State University as an addendum to Guide 3. Hillers and Dougherty note the only safe changes a home food preserver can make to their listed recipes is to substitute bottled lemon or lime juice for vinegar or to change the amount of spices and herbs. This project sought to create and test a guideline recipe for salsa that allowed for minor variations in low-acid ingredients, while maintaining a safe level of acidification from tomatoes and lemon juice. MATERIALS AND METHODS Figure 1. Guideline Salsa Recipe ~per pint jar ¼ cup lemon juice (60 ml) 200 g Roma tomatoes (peeled, deseeded, and diced to approx. ¼” ) ~ tomato juices were drained and discarded 200 g any combination of onions, bell peppers (diced to approx. ¼”) and pureed hot peppers including seeds ¼ tsp salt Processing: All of the ingredients were combined in a saucepan and brought to boil over medium heat with stirring. The heat was reduced and the salsa was simmered for three minutes. Salsa was packed into clean, hot, pint-size canning jars leaving a ½ inch headspace. Boiling water processing: Jar rims were wiped and standard metal two-piece lids were added; then the salsa was processed for 15 minutes in a boiling water canner using the standard consumer methods referenced in the USDA Complete Guide to Home Canning (2). Ingredients All foods were obtained from a national grocery chain. Vegetables were of high quality (no bruising, firm and disease free) and were kept refrigerated until use. Acidifying agents were ReaLemon juice or ReaLime juice, and Kroger brand 5% acetic acid vinegar. Tomatoes were dipped in boiling water for 1-2 minutes until the skins wrinkled, then submerged into cold water. Loose skins were peeled off. Tomato flesh was cored, cut into pieces, and deseeded. The pieces were then cut into approximately ¼ inch cubes and the juices drained off through a colander. Onions and peppers were cut into approximately ¼ cubes. De-stemmed jalapeño peppers were puréed including seeds to maintain the capsaicin. Acidification of a tomato, onion, and pepper salsa Diced salsa ingredients (200 g Roma tomatoes, 120 g sweet onions, and 65 g sweet peppers), 15 g puréed jalapeño pepper, and 5 g salt were cooked with (¼ - ⅜ cup) vinegar, lemon juice or lime juice and canned in pint jars. The mixture was cooked, packed into hot pint jars, capped, and processed for 15 minutes (Figure 1.). After 24 h the product pH was determined from blended solids and brine. The goal was to obtain a quality product with a pH below 4.0 and closer to pH 3.8. Acidification of individual ingredients by lemon juice Lemon juice (0, 5, 10, 15, 20, 25, and 30 ml) was added to 100 g (¼” cubed) sweet green peppers, Roma tomatoes, white onions and hot (jalapeño) peppers. Each vegetable was placed into a half pint canning jar with the measured amount of lemon juice, and tap water to reach a ½” headspace. Three jars of each treatment were measured. Jar contents were cooked, repacked into hot jars, capped, and processed for 15 minutes (Figure 1.). After cooling overnight pH measurements were taken. Measurement of pH An Orion 520 A+ pH meter was used for all measurements. Readings were an average of three measurements made in different locations of the sample. A brine pH was determined by inserting the probe directly into the jar and reading the pH. A solids pH was determined for both un-rinsed solids and rinsed solids. The solids were drained in a U.S. standard No. 8 sieve inclined at a 17-20 degree angle for two minutes. For rinsed solids, 15 ml tap water was sprayed over the solids on the sieve and allowed to drain. Un-rinsed or rinsed solids were blended and the pH measurement was taken. Acidification of pepper and onion varieties by lemon juice Three varieties of sweet bell peppers (yellow, green and red) and three varieties of onions (yellow, white and purple) were cut into ¼ inch sized cubes and 200 grams of each were added to pint mason jars. Lemon juice (¼ cup) was added. Tap water, if needed, was used to top jars to a ½ inch headspace. Jar contents were cooked, repacked into hot jars, capped, and processed for 15 minutes (Figure 1.). After cooling overnight pH measurements were taken. Acidification of excess quantities of low acid vegetable by lemon juice Three varieties of sweet bell peppers (yellow, green and red) and three varieties of onions (yellow, white and purple) were cut into ¼ inch sized cubes. The maximum volume of vegetable was pressed into pint mason jars allowing for a ½” headspace; fill weights were recorded. Lemon juice (¼ cup) was added. Tap water, if needed, was used to top jars to a ½ inch headspace. The jar contents were cooked, packed into hot jars, capped, and processed in a boiling water canner for 15 minutes (Figure 1.). After cooling overnight pH measurements were taken. Slide3:  RESULTS Acidification of a tomato, onion, and pepper salsa Table 1. Salsa pH vs. Type and Amounts of Acid * 24-hour pH of blended product (solids and brine). Lemon and lime juice (1/4 cup per pint) provided the best acidification of the salsa to pH 3.8 – 4.0. Lemon juice had a milder flavor, while lime juice provided a lime flavor that would be appropriate to this type of salsa. Lemon juice was chosen to continue experiments. Acidification of tomatoes, peppers, and onions by lemon juice Lemon juice acidification curves were created for sweet green peppers, Roma tomatoes, white onions and hot (jalapeño) peppers (Figures 1A-D.). Lemon juice (15 ml) safely acidified 100 g of each vegetable to below pH 4.0. Brine and solids pH measurements were nearly identical indicating acid equilibration within the 24 h period. When 30 ml of lemon juice was added to 100 g of vegetable the pH was safely reduced for: sweet green peppers (pH <3.43), Roma tomatoes (pH <3.38), white onions (pH <3.44) and hot (jalapeño) peppers (pH <3.73). It was interesting to note that this skinned and deseeded Roma tomato flesh had a pH of 4.6-4.7. This was most likely due to loss of acid in the tomato juice that was intentionally not used to avoid a watery salsa. The data suggest that 30 ml bottled lemon juice will safely acidify 100 g of tomatoes, peppers, or onions; or some combination of these ingredients. Acidification of full pint volumes of onions, green peppers and jalapeño peppers Full pint volumes of low acid vegetables (onions or peppers) were combined with ¼ cup of lemon juice (60 ml) to determine if consumer error could lead to unsafe acid levels in the guideline salsa recipe. Several varieties of onions were packed tight into a pint jar and weighed. From 263 – 295 g fit into jars from nine replicates. The maximum pint volume of green peppers weighed from 296 – 304 g for three replicates. After adding lemon juice, cooking, and boiling water processing, the full pint volumes of acidified onions had a pH range from 3.59 – 3.82 and full pint volumes of acidified green peppers had a pH range of 3.66 – 3.80 (data not shown). Acidification of tomatoes, peppers, and onions by lemon juice and Roma tomato The experimental salsa recipe allows consumers to vary the quantity of low acid ingredients (onions and peppers) from 0-200 g per pint of salsa. Thus the acidification of single low acid vegetables by 200 g Roma tomato and ¼ cup lemon juice was examined. Table 2. pH of salsa made with 200 g Roma tomato, ¼ cup lemon juice and 200 g of single low acid vegetables * 24-hour pH of blended product (solids and brine). Slide4:  Quality and safety of an experimental salsa recipe From previous experiments it was determined that ¼ cup of lemon juice would safely acidify a salsa containing 200 g Roma tomatoes and 200 g low acid ingredients (onions, sweet peppers and hot peppers). Therefore the following experimental recipe was chosen for preliminary quality tests. Table 3. Guideline Recipe for Tomato-based Salsa Three replications of 9-pint jar batches were made of this salsa recipe. The guideline recipe for tomato-based salsa produced a salsa with a pH between 3.8 and 4.0. Some samples were subjected to an informal taste panel (four persons). The taste panel noted that the vegetables were crisp, had lots of color, and that the salsa was not too watery. The flavor was as expected for salsa and was not too spicy. DISCUSSION • Lemon juice (1/4 cup or 60 ml) safely acidified a guideline salsa recipe containing 200 g Roma tomatoes, 120 g onions, 65 g peppers, 15 g hot pepper purée, and ½ tsp salt to a pH below 4.0. The flavor and color of this salsa after canning was of acceptable quality based on preliminary tests. • Lime juice provided the same acidification of the salsa, but it had a much stronger lime flavor and aroma. • A larger volume of vinegar was needed to achieve equivalent pH values for the salsa mixture; this volume resulted in a pronounced flavor change. Acidification curves indicated that lemon juice (30 ml per 100 g vegetable) could safely acidify tomatoes, peppers, or onions prepared under the conditions in this experiment. • Salsa made from 200 g Roma tomatoes, ¼ cup bottled lemon juice and either all onions (200 g) or all green bell peppers (200 g) was safely acidified. • Using the correct amount of bottled lemon juice (1/4 cup per pint) full pint volumes of either onions or bell peppers are safely acidified. This helps provide a safer recipe despite the possibility of consumer error. This recipe is not yet being recommended for public use until there is further research and peer review. Validation with more replications and in larger batch recipes and heat penetration studies are needed. The final goal is a recipe that could be validated to allow consumers some measure of creativity in mixing their low-acid ingredients in a tomato-based salsa to maintain safe acidification for boiling water canning. REFERENCES 1. Hillers, V.A. and R. Dougherty. 1996 (revised 2000). Salsa Recipes for Canning. Washington State University Cooperative Extension Service. 2. USDA. 1994. USDA Complete Guide to Home Canning. Agriculture Information Bulletin No. 539. Available at: http://www.uga.edu/nchfp/publications/usda/utah_can_guide_00.pdf. Accessed 10 Jul 2004. ACKNOWLEDGEMENTS This research was performed by Megan Thacker, University of Georgia for Undergraduate Research credit. This material is based upon work supported by the Cooperative State Research, Education, and Extension Service, U.S. Department of Agriculture, under Agreement No. 00-51110-9762.

Related presentations


Other presentations created by Sudiksha

3 Theodore Roosevelt
22. 10. 2007
0 views

3 Theodore Roosevelt

ramasetu24june200747 69
30. 09. 2007
0 views

ramasetu24june200747 69

08 Tornado
05. 10. 2007
0 views

08 Tornado

ACEI New Orleans 2004
05. 10. 2007
0 views

ACEI New Orleans 2004

Breaking Bad News May 07 ASA
08. 10. 2007
0 views

Breaking Bad News May 07 ASA

DESIGNING A TEMPERATURE SENSOR
12. 10. 2007
0 views

DESIGNING A TEMPERATURE SENSOR

blackhole
07. 10. 2007
0 views

blackhole

quiz
10. 12. 2007
0 views

quiz

BSRUN
19. 10. 2007
0 views

BSRUN

E consultancy slides march 6th
25. 10. 2007
0 views

E consultancy slides march 6th

breakinggridlock0612 01
30. 10. 2007
0 views

breakinggridlock0612 01

EXPLORERS
01. 11. 2007
0 views

EXPLORERS

Japanl
09. 10. 2007
0 views

Japanl

oct16 gfbiedu
25. 10. 2007
0 views

oct16 gfbiedu

dbirday croft
16. 11. 2007
0 views

dbirday croft

KSA V5
23. 11. 2007
0 views

KSA V5

DavidShipman
04. 10. 2007
0 views

DavidShipman

Significance
25. 10. 2007
0 views

Significance

NASA
03. 01. 2008
0 views

NASA

Day 3 Charlotte DUFOUR TIPS
04. 12. 2007
0 views

Day 3 Charlotte DUFOUR TIPS

colangelo
07. 01. 2008
0 views

colangelo

pisa overview
17. 10. 2007
0 views

pisa overview

NG21A 07 Rundle
30. 10. 2007
0 views

NG21A 07 Rundle

McCarthypix
02. 11. 2007
0 views

McCarthypix

frital
24. 10. 2007
0 views

frital

Ammosov RPC IHEP
12. 10. 2007
0 views

Ammosov RPC IHEP

P4 2 Kawagoe
15. 10. 2007
0 views

P4 2 Kawagoe

PE Minerals
16. 02. 2008
0 views

PE Minerals

Internal Analysis Lecture
24. 02. 2008
0 views

Internal Analysis Lecture

OSHAtop102006
26. 02. 2008
0 views

OSHAtop102006

T E of the Machine Gun
27. 02. 2008
0 views

T E of the Machine Gun

secretcodes tcm4 336597
31. 12. 2007
0 views

secretcodes tcm4 336597

1960s
20. 02. 2008
0 views

1960s

Porteous
12. 03. 2008
0 views

Porteous

AG 2002 11 16
24. 10. 2007
0 views

AG 2002 11 16

Md  Ppt
24. 03. 2008
0 views

Md Ppt

science genetics
03. 10. 2007
0 views

science genetics

Grade 9 Heat
03. 04. 2008
0 views

Grade 9 Heat

Final Prelims 2006
16. 04. 2008
0 views

Final Prelims 2006

FOP01 Franchise Opportunity
17. 04. 2008
0 views

FOP01 Franchise Opportunity

pres4
18. 04. 2008
0 views

pres4

LSE
22. 04. 2008
0 views

LSE

B1
30. 10. 2007
0 views

B1

OPC Notes CT
07. 05. 2008
0 views

OPC Notes CT

chris corrigan pres
30. 04. 2008
0 views

chris corrigan pres

Facility Layout Lecture Notes
02. 05. 2008
0 views

Facility Layout Lecture Notes

Sukal Linger Presentation
08. 10. 2007
0 views

Sukal Linger Presentation

access programme 2004
17. 10. 2007
0 views

access programme 2004

SuperValu Presentation2
02. 10. 2007
0 views

SuperValu Presentation2

Larsen
07. 03. 2008
0 views

Larsen

cbm39 269
14. 04. 2008
0 views

cbm39 269

Cuban
23. 12. 2007
0 views

Cuban

ICN2001 Final Report for web
20. 03. 2008
0 views

ICN2001 Final Report for web

map ftaa windows xp
22. 10. 2007
0 views

map ftaa windows xp

The Motorola Phone Comedy
17. 10. 2007
0 views

The Motorola Phone Comedy

PresSchatanIntrod
22. 10. 2007
0 views

PresSchatanIntrod

ERCIMgridasiaRR
16. 10. 2007
0 views

ERCIMgridasiaRR

bpesp
23. 10. 2007
0 views

bpesp

Florida Congress 6 06
22. 10. 2007
0 views

Florida Congress 6 06

WrinkleInTime
24. 10. 2007
0 views

WrinkleInTime

WNVEnterpriseGIS Chicago
21. 10. 2007
0 views

WNVEnterpriseGIS Chicago

pira ing
04. 10. 2007
0 views

pira ing

SolarHeliosphere
11. 03. 2008
0 views

SolarHeliosphere

InstallingPortlets
05. 10. 2007
0 views

InstallingPortlets