GM Presentation

Information about GM Presentation

Published on November 15, 2007

Author: Bernadette

Source: authorstream.com

Content

Slide1:  2006MY General Motors Police Program Portfolio Overview 2006 Police Impala - 9C1:  2006 Police Impala - 9C1 2006 Police Impala - 9C1:  2006 Police Impala - 9C1 2006 Police Impala - 9C3:  2006 Police Impala - 9C3 2006 Police Impala - 9C1 & 9C3:  2006 Police Impala - 9C1 & 9C3 Product refinements Improved front occupant spaciousness 2006 Police Impala:  2006 Police Impala Improved Storage – Trunk:  Storage capacity maintained More than 18.5 cubic feet Improved Storage – Trunk 2006 Police Impala 9C1 & 9C3:  2006 Police Impala 9C1 & 9C3 Product refinements Improved front occupant spaciousness Improved powertrain and performance 3.9L V6 Engine:  3.9L V6 Engine 60-degree OHV V6 Two valves per cylinder Variable valve timing Variable intake manifold 240 horsepower @ 5700 rpm 245 lb.-ft. torque @ 2800 rpm 90% of peak torque from 1800 to 5800 rpm 4T65E Transmission:  4T65E Transmission Best-in-Class in J.D. Power Initial Quality Improvements for high-speed capability Performance Enhancements:  Performance Enhancements 2005 Impala 2006 Impala 0 – 60 mph Top Speed 8.7 seconds 123 mph 8.24 seconds 128 mph 2006 Police Impala - 9C1 & 9C3:  2006 Police Impala - 9C1 & 9C3 Product refinements Improved front seat occupant spaciousness Improved powertrain and performance Enhanced safety features Safety and Security:  Safety and Security 5-Star front crash performance Dual-stage air bags Air bag suppression for small occupants Strengthened safety cage Safety and Security:  Side-impact occupant protection Strengthen the ‘safety cage’ Extensive use of high-strength steel Safety and Security Safety and Security:  Side-impact occupant protection Strengthen the ‘safety cage’ Extensive use of high-strength steel Added and upgraded reinforcements Safety and Security Safety and Security:  Safety and Security 5-Star front crash performance Dual-stage air bags Air bag suppression for small occupants Strengthened safety cage Improved seat structure Safety and Security:  Side-impact occupant protection Under-seat structural tubes Center tunnel crush box Safety and Security Safety and Security:  Safety and Security 5-Star front crash performance Dual-stage air bags Air bag suppression for small occupants Strengthened safety cage Improved seat structure Seat belt pretensioners Optional roof rail air bags Safety and Security:  Roof rail air bag protection for front and rear passengers Coverage for full range of occupant sizes and seating positions Safety and Security Current R.R.A.B. Rationale:  Current R.R.A.B. Rationale Notice of proposed rule making Docket # NHTSA-2004-17694 Revised FMVSS 214 – Pole Test Estimated implementation 2008 2006 Impala designed to meet proposed requirement Voluntary global OEM rollout Current prisoner partition designs incompatible Proposed Resolution Strategy:  Proposed Resolution Strategy Continue to lead industry in safety initiatives Must be resolved by after market manufacturers After market clinic - May 25, 26, Detroit, MI Revised partitions Individual prisoner containment devices Cut-off switches Limited municipal participation if desired Report progress through GM L.E.P.C. 2006 Police Impala - 9C1 & 9C3:  2006 Police Impala - 9C1 & 9C3 Product Refinements Improved front seat occupant spaciousness Improved powertrain and performance Added safety features Improved electrical load management 150 amp DENSO Alternator :  150 amp DENSO Alternator with idle boost 2006 Police Impala - 9C1 & 9C3:  2006 Police Impala - 9C1 & 9C3 Product refinements Improved front seat occupant spaciousness Improved powertrain and performance Added safety features Improved electrical load management Industry first amenities Industry First Amenities:  Industry First Amenities Factory installed remote vehicle start Integral rear lamp flasher Standard power passenger seat – 9C1 Integrated storage tray with cup holders Integrated Storage Tray w/Cup Holders:  Integrated Storage Tray w/Cup Holders Early prototype Interior Updates:  Interior Updates Ebony & Cashmere Neutral interior colors Impala Interior Colors:  Impala Interior Colors Cashmere Neutral Ebony Interior Updates:  Interior Updates Ebony & Cashmere Neutral interior colors Cruise control - standard Revised speedometer – CERTIFIED flash Standard Driver Information Center with redundant speed display:  Standard Driver Information Center with redundant speed display Information Displayed Vehicle information menu: Oil Life index (and reset), English/Metric unit selection, front tire pressures / rear tire pressures / tire position learning (if equipped), compass zone setting / compass recalibration (if equipped), and remote key programming Comfort/Convenience Interior Updates:  Interior Updates Ebony & Neutral interior colors Cruise control - standard Revised speedometer – CERTIFIED flash Keyless entry standard Fleet Key Fob package Exterior Updates:  Exterior Updates Permanent DRL/AHL disable (9G8) Available rear spoiler Heated OSRVM’s available Ten new exterior colors Impala Exterior Colors:  Impala Exterior Colors White Light Tarnished Silver Dark Tarnished Silver Black Antique Bronze Cobalt Red Laser Blue Superior Blue Sport Red Blue Ice Chassis/Powertrain Updates:  Chassis/Powertrain Updates Improved auxiliary cooling Enhanced braking performance Improved transmission durability Increased alternator output P225/60R16 “Pirelli” tire – V rated Police Content Continuations:  Police Content Continuations HD Police suspension High-density seating with protective barrier in 9C1 Auxiliary power supplies and Police specific body wiring Police specific options Body side moldings remain non-removable Kerr turn-key program Police Content Discontinuations:  Police Content Discontinuations All vinyl interior Surveillance switch…now same as Tahoe Impala/Tahoe common fleet key – (6E2/6E8) New Feature Proposal:  New Feature Proposal Improved Rear Seat Functionality :  Improved Rear Seat Functionality Key to rear seat is the new, optional storage system – the first of its kind for a sedan in this market segment Program Timing:  Program Timing Brochure availability Mid June Pricing Mid June Order acceptance (Targeted) August Start of production (Targeted) 3rd. Qtr. 2006 Tahoe PPV Police Package:  2006 Tahoe PPV Police Package Carryover for 2006 2006 4x4 Special Service Package:  2006 4x4 Special Service Package 4.8L engine no longer available 5.3L engine is standard  StabiliTrak will be standard Tahoe Program Updates:  Tahoe Program Updates 2006 MY Police Tahoe buildout Oct. 31 Final Orders due – (estimate) Mid-Sept. ’05 eFleet product availability 2000-3000 units 2007 MY start of production 4th qtr. ’06 Letter of Intent – 9/1/05 Build & hold 2006 Chevy Express Transport Van:  2006 Chevy Express Transport Van Carryover for 2006 2006 HUMMER H1:  Minor changes for 2006 2006 HUMMER H1 Problem Reports:  Problem Reports Earl Gautsche National Police Fleet Service Manager Group 1 – Body Integrity:  Group 1 – Body Integrity City of Sioux City, IA 2001-02 Impala 50-60K 20 Units Problem: Both rear outside door handles (especially R/R) snap off at the handles. Front door handles are used 100x more and don’t break Response: Handles upgraded 12-13-02, same part number as previous (Over travel) Group 1 – Body Integrity:  Group 1 – Body Integrity Thurston County, WA 2004 Blazer Problem: Rear tailgate latch failure. Latch will pop open when car is put in park Response: Possible electrical problem – No other reported problems Group 2 – Interior Environment:  Group 2 – Interior Environment City of Decatur, IL 2004 Impala 0-30K 10 Units Problem: Speedometer / temperature / fuel gauge inaccurate Response: Stepper motors stick. Production upgrade July ‘04. Special part # for Police vehicle cluster. Cluster must be sent out for repairs Group 2 – Interior Environment:  Group 2 – Interior Environment Jefferson County Sheriff, Jefferson County, CO 2004 Tahoe 0-10K 12 Units Problem: Inoperative Speedometer – requires instrument cluster replacement Response: Same as previous. Stepper motors stick. Production upgrade July ‘04. Special part # for Police vehicle cluster Cluster must be sent out for repairs Group 2 – Interior Environment:  Group 2 – Interior Environment London Police Service, London, ONT, Canada 2001-3 Malibu/Alero 10-30K 39 Units Problem: Heater fan resistor board develops an open circuit. (Malibu/Alero) Heater control and fans – Two push in buttons break Response: Under investigation. Need more information Group 3 – Drivetrain:  Group 3 – Drivetrain City of Decatur, IL 2004 Impala 10-30K 2 Units Problem: Excessive oil consumption Response: Valve stem oil seals. Dealer documentation ID # 837352, 651941, & 747694 for repair. (See Handout) Group 3 – Drivetrain:  Group 3 – Drivetrain City of Sioux City, IA 2004 Impala 0-10K 6 Units Problem: The low oil light comes on before the oil change interval of 2,000 miles. Only 2004’s with 3.8 liter engine using oil…not a problem on previous years. From brand new, the 2004’s used 1 ½ quarts oil in1500 miles (lots of idling time also) Response: Same as previous. Valve stem oil seals. Dealer documentation ID # 837352, 651941, & 747694 for repair Group 3 – Drivetrain:  Group 3 – Drivetrain City of Decatur, IL 2001 Tahoe 20-30K 2 Units Problem: Lifter noise. GM dealer says lifter noise is normal Response: See Service Bulletin # 02-06-01-038 and document ID # 1206539 pertaining to aeration of oil and oil pump “O” ring seal. (See Handout) Group 3 – Drivetrain:  Group 3 – Drivetrain City of Sioux City, IA 2001-03 Impala 30-40K 20 Units Problem: Engine and transmission mounts are not heavy enough to handle the rough service. As lower mounts give out the clamp on CV boot can rub the on frame and when clamp comes off, the grease flies out Response: See Service Bulletin # 02-03-08-002 and document ID # 854087 for repair (See Handout) Group 3 – Drivetrain:  Group 3 – Drivetrain City of Beaumont, TX 2001-03 Impala 50-60K 60 Units Problem: Transmission failure. Availability of remanufactured transmission is poor Response: Due to continuous improvement process on transmission durability it is recommended local GM Rep be contacted to identify and resolve specific issues. Ask speedy delivery of transmission via SPAC case Group 4 – Drivability:  Group 4 – Drivability City of Sioux City, IA 2001-03 Impala 20-90K 20 Units Problem: Rubber donut used as exhaust hanger, only 12” from catalytic converter, hardens and breaks from excessive heat. These hangers are continually replaced on Impala Police cars every 20-30k miles Response: Under investigation. Need failed parts Group 4 – Drivability:  Group 4 – Drivability City of Decatur, IL 2001 Tahoe 20-40K 2 Units Problem: Low idle speed Response: See Service Bulleting # 04-06-04-079 for carbon buildup at throttle plate. (See Handout) Check TPS switch Group 4 – Drivability:  Group 4 – Drivability Thurston County, WA 2002 Blazer 75K Problem: Fuel pump failures @ 75,000 miles Response: Isolated problem – under investigation – fuel sock? Armature? More information needed. Group 4 – Drivability:  Group 4 – Drivability City of Tulsa, OK Equipment Mgmt. Dept. 2001-03 Impala 20-40K Problem: Rear exhaust manifolds cracking Response: See Service Bulletin # 03-06-05-002 catalytic converter. New stamped rear exhaust manifold heat shield plus revisions to manifold to accept shield implemented 10/1/02. Revised calibration to enrich mixture and cool exhaust gases implemented 2001 SOP. Contact local GM Rep for specific replacement information. Part # Manifold 12576864; Shield 12588277; Bolts (4) 11519964; Heat Shield for knock sensor 24506490. (See Handout) Group 4 – Drivability:  Group 4 – Drivability City of Tulsa, OK Equipment Mgmt. Dept. 2001-03 Impala 20-40K Problem: Intake manifolds cracking Response: Increased material thickness in late 2003 MY. Non-issue in 2004 Group 5 – Brakes:  Group 5 – Brakes London Police Service London, ONT, Canada 2001-03 Alero/Malibu 10-20K 23 Units Problem: All brakes rotors rust Response: Under investigation. Need more information Group 6 – Handling:  Group 6 – Handling City of Colorado Springs, CO Police Department 2002-03 Impala 15K 125 Units Problem: Outer tie-rod ends premature failure Response: See Service Bulletin # 02-02-32-006 for information on Police Vehicle Only repair. Replacement part # 26086580 Note: Special Tie Rod for Police Vehicles is different from retail vehicles (See Handout) Group 6 – Handling:  Group 6 – Handling City of Colorado Springs, CO Police Department 2002-03 Impala 15-30K 50 Units Problem: Front hub bearings Response: New bearing preloaded from OEM with hub assembly and added grease volume. Started MY 2004 Group 8 – Cooling System:  Group 8 – Cooling System City of Sioux City, IA 2001-03 Impala 20-90K 20 Units Problem: Radiator fans are noisy or don’t run at all. Radiator fan assemblies being changed approximately every 30K for defective fan motors. Noisy fans ultimately will stop and all vehicles experience overheating of engine and transmission Response: See Service Bulletin # 02-06-02-011A and document ID # 1212681 for repair. Fan motors available as separate units in 2004. (New Supplier) (See Handout) Group 8 – Cooling System:  Group 8 – Cooling System City of Colorado Springs, CO Police Department 2002-03 Impala 10-30K 125 Units Problem: Cooling fan failure (Bearings) Response: See previous answer. See Service Bulletin # 02-06-02-011A and document ID # 1212681 for repair. Fan motors available as separate units in 2004. (New Supplier) Group 9 – Other:  Group 9 – Other No issues! Service Notifications:  Service Notifications 2005 Tahoe - Noncompliance Recall 05023 Shift lever position indicator illumination 2005 Tahoe - Product Safety Recall 04066 Fuel rail crossover tube retainer screws – Replace 2004 Tahoe – Noncompliance Recall 04004 Brake hydro-boost relief valve seal fracture 2005 Tahoe – Customer Satisfaction 04065 Liftgate window molding Service Notifications:  Service Notifications 2004 Impala – Product Safety Recall 04049 Front brake caliper bolt torque 2000-03 Impala - Customer Satisfaction Program 03034 Engine coolant leak 2003 Impala – Customer Satisfaction Program 04062A Engine oil cooler adaptor fittings 2000 Product Safety Recall 03054B Fuel pressure regulator - replace Slide71:  2006MY General Motors Police Program Portfolio Overview

Related presentations


Other presentations created by Bernadette

Article Usage
16. 11. 2007
0 views

Article Usage

halloween safety
05. 11. 2007
0 views

halloween safety

Oral Cancer
04. 01. 2008
0 views

Oral Cancer

service
03. 10. 2007
0 views

service

AMATYC 2004 Orlando Talk
06. 12. 2007
0 views

AMATYC 2004 Orlando Talk

16 graph design2
05. 11. 2007
0 views

16 graph design2

Astro105 Lecture13
14. 11. 2007
0 views

Astro105 Lecture13

aafsurvey 2006
16. 11. 2007
0 views

aafsurvey 2006

The Real Water World
01. 01. 2008
0 views

The Real Water World

Asteroid Mining
02. 01. 2008
0 views

Asteroid Mining

State Space Intro show
03. 01. 2008
0 views

State Space Intro show

Dali parteI
05. 01. 2008
0 views

Dali parteI

peer relationship2
28. 12. 2007
0 views

peer relationship2

ladisch purdue
04. 01. 2008
0 views

ladisch purdue

TeamSystem2008Overvi ew
01. 12. 2007
0 views

TeamSystem2008Overvi ew

2005 4160s2 06 Fasano
04. 10. 2007
0 views

2005 4160s2 06 Fasano

digitisation and data capture
27. 02. 2008
0 views

digitisation and data capture

patryk
19. 12. 2007
0 views

patryk

PP O2Dock
29. 02. 2008
0 views

PP O2Dock

Editorial Policy and Process
04. 12. 2007
0 views

Editorial Policy and Process

costianes
05. 03. 2008
0 views

costianes

Export Presentation
14. 03. 2008
0 views

Export Presentation

2 Poster 5 Grant
21. 12. 2007
0 views

2 Poster 5 Grant

recitationreviewv2
13. 04. 2008
0 views

recitationreviewv2

montes inaoep
28. 11. 2007
0 views

montes inaoep

13 1
17. 12. 2007
0 views

13 1

Podzim v Chicagu
05. 11. 2007
0 views

Podzim v Chicagu

bioterrorism new
27. 12. 2007
0 views

bioterrorism new

BlacksburgConcl2
12. 12. 2007
0 views

BlacksburgConcl2

E2005 1 347788 EteSeance5
27. 11. 2007
0 views

E2005 1 347788 EteSeance5

SONIA MENNA BARRETO 01
01. 11. 2007
0 views

SONIA MENNA BARRETO 01

Envir100LectOct29
21. 11. 2007
0 views

Envir100LectOct29

welinski 2
28. 11. 2007
0 views

welinski 2

OHP9b PCA 2006
23. 11. 2007
0 views

OHP9b PCA 2006