maningas

Information about maningas

Published on November 8, 2007

Author: Wen12

Source: authorstream.com

Content

Modular Biotreatment Systems Versus Oil-Water Separators:  Modular Biotreatment Systems Versus Oil-Water Separators A Comparison of Pretreatment Technologies Mario Maningas Clean Water Program Naval Air Station Patuxent River Oil-Water Separators (OWS) at NAS Patuxent River:  Oil-Water Separators (OWS) at NAS Patuxent River Thirty (30) oil-water separators Aircraft Washracks Aircraft Hangars Military Vehicle Washracks / Transportation Building Jet Engine Test Cells Building Mechanical Process / Process Wastewater Discharge to sanitary collection system and state waters (Chesapeake Bay) 1986 Oil Water Separator Report OWS on base are poorly maintained Used on wastewaters where they have little effect Soluble oils Emulsified oils Designed to remove free oils Oil-Water Separators (OWS) at NAS Patuxent River:  Oil-Water Separators (OWS) at NAS Patuxent River Operations and Maintenance Manual developed in 1997 Estimated program costs (Preventive Maintenance & Cleaning) Emergency response - $3,500 Annual cost (daily inspection) - $6,890 190 hours per unit / year Check sediment and oil depths Annual cost (weekly inspection) - $1,600 44.40 hours per unit / year Check sediment and oil depths Sampling for cleanout (TCLP) - $800 Annual cleanout (non-regulated waste) - $1,200 $0.75 / gallon Based on average OWS capacity – 1,600 gallons Annual cleanout (Hazardous waste) - $2,500 $1.50 / gallon Based on average OWS capacity – 1,600 gallons Steam cleaning or citric acid cleaning, and inspection - $100 Annual repairs - $500 ESTIMATED TOTAL ANNUAL COST: $4,200 to $12,000+ Are OWS truly effective? Other Available Technologies:  Other Available Technologies Crossflow filtration Ultrafiltration, Nanofiltration, Hyperfiltration (Reverse Osmosis) Chemical Absorption Separators Chemical media to attract oil and repel water Mechanical Absorption Separators Coalescer / pressure Vaporization OWS External heat source boils off water and leaves oil Biological Remediation Modular Biotreatment System:  Modular Biotreatment System Why Choose This System? No mechanical filters or filter mediums No ozone, chlorides, or peroxides Aerobic system – virtually no odor Uses indigenous bacteria The system maximizes the conditions to promote development of aerobic bacteria Organic pollutants are consumed instead of filtered out Low Maintenance (10 minutes per week) Check lights and water level Water Quality Guarantee Oxygen > 60% Oil emulsion < 5 PPM TDS < 1,500 mg/l Conductivity < 2,000 micro siemens Particle size < 5 microns pH value 6.0 – 8.0 BOD < 150 mg/l COD reduction 1:10 Sites:  Sites Transportation Building Jet Engine Test Cell Steam Catapult Transportation Building:  Transportation Building Base vehicle maintenance Vehicle washings Potential pollutants of concern Petroleum products Fuels, oils, greases Surfactants (detergents) Glycols (antifreeze) Transportation Building (OWS):  Transportation Building (OWS) Influent Pit (1-29-2004) Effluent Pit (1-29-2004) Jet Engine Test Cell:  Jet Engine Test Cell Wastewater generated from a FOD washdown, and after-burn exhaust cooling Wastewater generated during operation – 5,000 gallons Two OWS in service Potential pollutants of concern Petroleum products Fuels, oils, greases Glycol (from fuels) Jet Engine Test Cell (OWS):  Jet Engine Test Cell (OWS) Jet Engine Test Cell (OWS):  Jet Engine Test Cell (OWS) Steam Catapult (OWS):  Steam Catapult (OWS) Wastewater generated – 3,750 gallons per launch Approximately 1 gallon of lube oil and grease is generated per launch Water Brake Tank (5,000 gallons) is drained after 50 launches Four OWS service the activity Potential pollutants of concern Petroleum products Fuels, oils, greases Glycol (from fuels) Steam Catapult (OWS):  Steam Catapult (OWS) Biotreatment System Flow Chart:  Biotreatment System Flow Chart Installation (General info):  Installation (General info) Site approval Above-ground or Below-ground system Above-ground is less expensive and quicker/easier to install Concrete foundation Container (conex box) to protect system from weather / climate Installation (Transportation):  Installation (Transportation) Cost for installation ≅ $63,000 Design Bioreactor (500 gph) Two 500-gallon tanks (aeration & reuse) Pumps Excavation Concrete pad Power hookup Piping Container (conex box) Labor Thermostat controlled infrared heaters Ventilation Two week installation time Installation (Jet Engine Test Cell):  Installation (Jet Engine Test Cell) Cost for installation ≅ $115,000 Design Two bioreactors (1,000 gph) 1000-gallon aeration tank, 250-gallon reuse tank Pumps Excavation (tying in two OWS) Skimmer for second OWS Concrete pad Power hookup Piping Container (conex box) Labor Thermostat controlled infrared heaters Ventilation Two – three week installation time Wastewater Sampling Comparison (Transportation):  Wastewater Sampling Comparison (Transportation) Transportation Aeration Tank:  Transportation Aeration Tank 03-02-2004 03-04-2004 03-09-2004 Transportation Reuse Tank:  Transportation Reuse Tank 03-04-2004 03-09-2004 Wastewater Sampling Comparison (Jet Engine Test Cell):  Wastewater Sampling Comparison (Jet Engine Test Cell) * System not in full operation Jet Engine Test Cell OWS Pit :  Jet Engine Test Cell OWS Pit Yearly Maintenance:  Yearly Maintenance Oil-Water Separator Maintenance Estimated Yearly Maintenance Cost - $4,200 - $12,000 Preventive Maintenance Cleanouts Bioreactor maintenance Weekly, quarterly, and annual inspections ($50 / hour) - $2,000 Weekly – 30 minutes Quarterly – 1 hour Annual – 2 hours 90-day nutrient bag replacement ($276) – yearly cost $1,104 Estimated Yearly Maintenance Cost - $3,200 - $4,000 Comparison: Oil-Water Separator vs. Bioreactor:  Comparison: Oil-Water Separator vs. Bioreactor Future Impacts:  Future Impacts Aircraft Wash Racks Closed-loop systems for water conservation Potential treatment/disposal of oil-contaminated water from spills Pretreatment alternative for other activities with petroleum or other organic pollutant issues Acknowledgements:  Acknowledgements

Related presentations


Other presentations created by Wen12

Rajasthan07 08
01. 01. 2008
0 views

Rajasthan07 08

APA
28. 09. 2007
0 views

APA

THE METADATA LANDSCAPE
03. 12. 2007
0 views

THE METADATA LANDSCAPE

An overview of the Cold War
25. 12. 2007
0 views

An overview of the Cold War

lecture33
27. 09. 2007
0 views

lecture33

FyrirlesturBenjaminB T1
01. 10. 2007
0 views

FyrirlesturBenjaminB T1

ch07
04. 10. 2007
0 views

ch07

Reproductive System
10. 12. 2007
0 views

Reproductive System

Chapter29
11. 12. 2007
0 views

Chapter29

NYMA March 1 2006
12. 12. 2007
0 views

NYMA March 1 2006

Irritable Bowel Syndrome
30. 10. 2007
0 views

Irritable Bowel Syndrome

lect28 acts
06. 11. 2007
0 views

lect28 acts

historischer abriss
13. 11. 2007
0 views

historischer abriss

vestibular
19. 11. 2007
0 views

vestibular

en pressrelease gm 1175176873
20. 11. 2007
0 views

en pressrelease gm 1175176873

ipv6 ntt
26. 11. 2007
0 views

ipv6 ntt

SMS quiz
13. 12. 2007
0 views

SMS quiz

Modern Dance
14. 12. 2007
0 views

Modern Dance

usaasean
23. 12. 2007
0 views

usaasean

The Great Plains
27. 12. 2007
0 views

The Great Plains

Early Stage Funding
28. 12. 2007
0 views

Early Stage Funding

topology CUCL 20040408
01. 12. 2007
0 views

topology CUCL 20040408

LegoChall07Web
07. 01. 2008
0 views

LegoChall07Web

61 Schaller Titan
14. 11. 2007
0 views

61 Schaller Titan

f2f
26. 10. 2007
0 views

f2f

turtle
20. 11. 2007
0 views

turtle

shs
07. 12. 2007
0 views

shs

Flaxmere Primary Planting Day
26. 11. 2007
0 views

Flaxmere Primary Planting Day

leb 98 dcs
31. 10. 2007
0 views

leb 98 dcs

8 Wirgentius
20. 02. 2008
0 views

8 Wirgentius

060302 3
24. 02. 2008
0 views

060302 3

vaughn
27. 02. 2008
0 views

vaughn

2007 Math PSAE
16. 11. 2007
0 views

2007 Math PSAE

PHYTO1
05. 03. 2008
0 views

PHYTO1

malaysia siewhoon06
27. 03. 2008
0 views

malaysia siewhoon06

PMPresentation
30. 03. 2008
0 views

PMPresentation

aspen2005tilav
12. 11. 2007
0 views

aspen2005tilav

Ship Heading Control
05. 11. 2007
0 views

Ship Heading Control

17 Filip Korinek
15. 11. 2007
0 views

17 Filip Korinek

nfs05 aug23 assessment
17. 12. 2007
0 views

nfs05 aug23 assessment

fitc flash flex
28. 11. 2007
0 views

fitc flash flex

p25 liu h
28. 11. 2007
0 views

p25 liu h

20060630 search strategies
14. 11. 2007
0 views

20060630 search strategies

Noah and the great flood 2 of 10
03. 10. 2007
0 views

Noah and the great flood 2 of 10

EarlyChristianity
01. 11. 2007
0 views

EarlyChristianity

APP The American Experience WK7
22. 11. 2007
0 views

APP The American Experience WK7

thaidance
27. 11. 2007
0 views

thaidance

Ibaraki
06. 11. 2007
0 views

Ibaraki

TAKAOforINMARTECH
05. 11. 2007
0 views

TAKAOforINMARTECH

polo Enigma
04. 01. 2008
0 views

polo Enigma

Yashinsky 22 May 2002 bridge DVs
30. 12. 2007
0 views

Yashinsky 22 May 2002 bridge DVs