Maxle

Information about Maxle

Published on February 29, 2008

Author: Herminia

Source: authorstream.com

Content

Maxle:  Maxle By Silent Drive, Inc. How Do I Maximize My Payload:  How Do I Maximize My Payload Past Trucks and bodies were built smaller Could max your capacity and be legal weight Federal bridge laws were not enforced How Do I Maximize My Payload:  How Do I Maximize My Payload Present Trucks and bodies are larger Can’t max your load without being overweight Answer add load carrying axles Still had a problem with overall bridge to max out capacity How Do I Maximize My Payload:  How Do I Maximize My Payload Future Need to lengthen the bridge with load carrying axle But not inhibit the operation of the truck Put the axle where it pays the most! Introducing the Maxle:  Introducing the Maxle DB series FL series FM series Maxle - DB:  Maxle - DB For dump bodies Does not impede loading or dumping applications while stowed in up position Raises and lowers with standard P.T.O. Air ride suspension for a softer ride 80 inch track steer axle offers maximum stability Maxle - DB:  Maxle - DB 7 axle Super Dump 80,000 lb. GVW Federal Bridge Maxle - DB:  Maxle - DB Does Not Restrict Unloading into Paver! Maxle - DB:  Maxle - DB Full body open for loading with Maxle raised. Why the Maxle vs. Competition:  Why the Maxle vs. Competition Air ride suspension vs. hydraulic pressure for smoother and safer ride Lightweight to maximize productive profit on increased payload Total modular unitized construction offers reduced installation time and cost Allows side loading while raised Improved stability for driver comfort and confidence Load Stability:  Load Stability Maxle Competition Rear view of Air Ride:  Rear view of Air Ride Full 80” track axle Load supported by Air Springs at frame width for stability Axle Travel :  Axle Travel When traveling through a sever dip the cylinders will contract a few inches until pressures exceed a safe level. The Maxle will then release notifying the driver that the Maxle is de-energized. When the driver is through the dip they push the down switch powering down the Maxle again. Maxle Prerequisites:  Maxle Prerequisites 1. Maxle should be supplied with a minimum of 15 GPM of flow from a solenoid operated motor spool type control valve where the A and B ports go to the tank in the center position. This can either be a stand alone valve or and additional section in a stack valve. 2. Overall relief should be set at 2500 psi minimum. 3. Hydraulic circuit should have a 10 micron absolute return line filter installed along with a 10 micron breather element on the hydraulic tank. 4. Silent Drive leaves the design of the hoist strictly up to the hoist manufacture, experience has shown that the extra weight of the Maxle-DB usually requires a double acting hoist to lower the body. 5. Customer needs to supply four 2 inch hinge pins for mounting the Maxle. Items included with Maxle-DB package:  Items included with Maxle-DB package 1. Control tower 2. Accumulator with a pre-charge of 2100 psi 3. Valve Block 4. Maxle-DB Frame (assembled), swivel frame, air ride suspension w hub & drums, additional air tank, lights, airlines, 2 hydraulic cylinders, air cylinder,air valve solenoid, and is pre-wired for light hookup to truck. 5. AC-2000 Air Control 6. Fenders and Mud-flaps 7. All Warning Decals Maxle-ize:  Maxle-ize Get the most of every trip you make Maximize your load capacity on every trip Body has 100% product utilization (DB and FL units) Slide17:  Typical generic chassis setup Slide18:  Typical generic chassis setup Slide19:  With extra payload, owners tell us they have customers requesting the truck with the Maxle! Owner Feedback ROI work sheet - Short Haul:  ROI work sheet - Short Haul Maxle - DB Truck with Maxle (6 axles, 36’ bridge) vs. without Maxle (5 axles, 24’ bridge) Additional cost for truck with the Maxle $30,000 Extra payload with the Maxle = 5 ton Short Haul (5 to 10 miles) Revenue = $1.50 per ton Average of 18 loads per day Work week = 6 days $1.50 x 5 ton = $7.50 more revenue per load $7.50 x 18 loads per day = $135.00 per day, $135.00 x 5 days = $675.00 per week $30,000 / $675 = 44.4 weeks of work to payback cost of the Maxle 1 Season! ROI work sheet - Short Haul:  ROI work sheet - Short Haul Maxle - DB, states that allow a max. of 4 axles Truck with Maxle (4 axles, 36’ bridge) vs. Regular (3 axle, 20’ bridge) Additional cost for truck with the Maxle =$30,000 Extra payload with the Maxle = 5 ton Short Haul (5 to 10 miles) Revenue = $1.50 per ton Average of 18 loads per day Work week = 5 days $1.50 x 5 ton = $7.50 revenue per load $7.50 x 18 loads per day = $135.00 per day, $135.00 x 5 days = $675.00 per week $30,000 / $675 = 44.4 weeks of work to payback cost of the Maxle Still less than 1 Season! ROI work sheet - Long Haul :  ROI work sheet - Long Haul Maxle - DB Truck with Maxle (6 axles, 36’ bridge) vs. without Maxle (5 axles, 24’ bridge) Additional cost for truck with the Maxle $30,000 Extra payload with the Maxle = 5 ton Long Haul (average of 30 loaded miles) Revenue = $ .11 per ton per loaded mile Average of 8 loads per day Work week = 5 days $ .11 x 5 ton x 30 miles = $16.50 more revenue per load $16.50 x 8 loads per day = $132.00 per day, $132.00 x 5 days = $660.00 per week $30,000 / $660 = 45.5 weeks of work to payback cost of the Maxle 1 Season! ROI work sheet - Long Haul:  ROI work sheet - Long Haul Maxle - DB, states that allow a max. of 4 axles Truck with Maxle (4 axles, 36’ bridge) vs. Regular (3 axle, 20’ bridge) Additional cost for truck with the Maxle = $30,000 Extra payload with the Maxle = 5 ton Long Haul (average of 30 loaded miles) Revenue = $ .11 per ton per loaded mile Average of 8 loads per day Work week = 5 days $ .11 x 5 ton x 30 miles = $16.50 more revenue per load $16.50 x 8 loads per day = $132.00 per day, $132.00 x 5 days = $660.00 per week $30,000 / $660 = 45.5 weeks of work to payback cost of the Maxle Still less than 1 Season! Distribution:  Distribution Maxle-DB series, must be coordinated with body manufacture May be installed at distributor if body is designed to accept the Maxle-DB Maxle:  Maxle By Silent Drive, Inc.

Related presentations


Other presentations created by Herminia

Vortrag Thomas und Heinrich Mann
01. 10. 2007
0 views

Vortrag Thomas und Heinrich Mann

lecture24 ecg
13. 04. 2008
0 views

lecture24 ecg

meslin
30. 03. 2008
0 views

meslin

FieldPlaceIES
27. 03. 2008
0 views

FieldPlaceIES

Mcqueen
14. 03. 2008
0 views

Mcqueen

Newman
05. 03. 2008
0 views

Newman

TaoYu
27. 02. 2008
0 views

TaoYu

NewAbsolutes
24. 02. 2008
0 views

NewAbsolutes

Lewis Giurato
20. 02. 2008
0 views

Lewis Giurato

Duncan SOLE 2005
07. 01. 2008
0 views

Duncan SOLE 2005

rim
10. 12. 2007
0 views

rim

pws
03. 10. 2007
0 views

pws

56202
29. 10. 2007
0 views

56202

dslpresent
28. 11. 2007
0 views

dslpresent

limits
28. 11. 2007
0 views

limits

iacopini
28. 11. 2007
0 views

iacopini

11 3 Water Underground
04. 12. 2007
0 views

11 3 Water Underground

NeGPSemWB
07. 12. 2007
0 views

NeGPSemWB

granlibachen
12. 12. 2007
0 views

granlibachen

lp5
25. 10. 2007
0 views

lp5

blondin
29. 10. 2007
0 views

blondin

Tank Cleaning Process
06. 11. 2007
0 views

Tank Cleaning Process

maria y adriana1
12. 11. 2007
0 views

maria y adriana1

Tied Up
16. 11. 2007
0 views

Tied Up

Nancy Nov03
20. 11. 2007
0 views

Nancy Nov03

Fri 1215 1300 Main Ann Doyle
22. 11. 2007
0 views

Fri 1215 1300 Main Ann Doyle

chioffi
26. 11. 2007
0 views

chioffi

JoiningSFP
27. 11. 2007
0 views

JoiningSFP

dominican republic
13. 12. 2007
0 views

dominican republic

sixties
14. 12. 2007
0 views

sixties

Case Studies
17. 12. 2007
0 views

Case Studies

KAIST 2002F Auction Oct 8
05. 11. 2007
0 views

KAIST 2002F Auction Oct 8

Ecomap Presentation
29. 12. 2007
0 views

Ecomap Presentation

danielle constantine senior case
02. 11. 2007
0 views

danielle constantine senior case

IAP99 Comp Robots Poster
31. 12. 2007
0 views

IAP99 Comp Robots Poster

ext mendel
01. 01. 2008
0 views

ext mendel

Budget hearing 08
02. 01. 2008
0 views

Budget hearing 08

Introduction to Robotics
04. 01. 2008
0 views

Introduction to Robotics

15 implant
04. 01. 2008
0 views

15 implant

Infecciones Emergentes
24. 10. 2007
0 views

Infecciones Emergentes

DemonstrationofAgriB ase2006
05. 01. 2008
0 views

DemonstrationofAgriB ase2006

lect28 handout
06. 11. 2007
0 views

lect28 handout

KyotoBH2003 Narayan
15. 11. 2007
0 views

KyotoBH2003 Narayan

I OPDS
05. 11. 2007
0 views

I OPDS

vipm 083007
26. 10. 2007
0 views

vipm 083007

AEC2004
19. 11. 2007
0 views

AEC2004

THE CUBAN REVOLUTION
11. 12. 2007
0 views

THE CUBAN REVOLUTION

sess4pr3
29. 10. 2007
0 views

sess4pr3

ElaborationPart2
05. 11. 2007
0 views

ElaborationPart2

intrcult
28. 09. 2007
0 views

intrcult

CelebratingHolidays
06. 11. 2007
0 views

CelebratingHolidays

GalvestonDialogueCop yrighted
25. 12. 2007
0 views

GalvestonDialogueCop yrighted

ISOC report ICANN 0403
29. 10. 2007
0 views

ISOC report ICANN 0403

SEAaT San Fran Pilot
07. 11. 2007
0 views

SEAaT San Fran Pilot

dxwang ACO2007
29. 11. 2007
0 views

dxwang ACO2007

3 EDGE piro
01. 11. 2007
0 views

3 EDGE piro

board 1199
14. 11. 2007
0 views

board 1199

mannivanovferbereng
27. 09. 2007
0 views

mannivanovferbereng

actaDiurna
31. 10. 2007
0 views

actaDiurna