Nitrogen Asphyxiation Bulletin

Information about Nitrogen Asphyxiation Bulletin

Published on November 12, 2007

Author: Columbia

Source: authorstream.com

Content

Slide1:  US Chemical Safety and Hazard Investigation Board The Hazards of Nitrogen Asphyxiation Introduction:  Introduction Nitrogen makes up 78% of the air we breath; because of this it is often assumed that nitrogen is not hazardous. However, nitrogen is safe to breath only if it is mixed with an appropriate amount of oxygen. Additional nitrogen (lower oxygen) cannot be detected by the sense of smell. Introduction :  Introduction Nitrogen is used commercially as an inerting agent to keep material free of contaminants (including oxygen) that may corrode equipment, present a fire hazard, or be toxic. A lower oxygen concentration (e.g., caused by an increased amount of nitrogen) can have a range of effects on the human body and can be fatal if if falls below 10% Effects of Oxygen Deficiency on the Human Body:  Effects of Oxygen Deficiency on the Human Body Source: Compressed Gas Association, 2001 Statistics on Incidents :  Statistics on Incidents CSB reviewed cases of nitrogen asphyxiation that occurred in the US between 1992 and 2002 and determined the following: 85 incidents of nitrogen asphyxiation resulted in 80 deaths and 50 injuries. The majority of incidents occurred in manufacturing and industrial settings, but several incidents occurred in other settings including laboratories and medical facilities. Facilities and Areas Where Incidents Occurred:  Facilities and Areas Where Incidents Occurred Statistics on Incidents (cont’d) :  Statistics on Incidents (cont’d) The majority of incidents occurred in and around confined spaces, though several incidents occurred in “open” areas, including inside buildings and outdoors near equipment. Almost half the incidents involved contractors, including construction workers. Contractors account for over 60% of the fatalities. Statistics on Incidents (cont’d) :  Statistics on Incidents (cont’d) Causes of the incidents included: Failure to detect an oxygen-deficient atmosphere in and around confined spaces. Mistakenly using nitrogen instead of breathing air. Inadequately preparing for rescue. Data Sources for Statistics :  Data Sources for Statistics Data sources for the CSB review included regulatory agencies, media reports, technical publications, and contacts with safety personnel; however, only those incidents that were reported and accessible are evaluated. Statistical analysis is based on the available, limited information. Although the summary data reported above are not all-inclusive, the numbers clearly indicate that nitrogen asphyxiation presents a serious hazard in the workplace. Case Study: Failure to Recognize Asphyxiation Hazards Near Confined Spaces :  Case Study: Failure to Recognize Asphyxiation Hazards Near Confined Spaces Three workers were cleaning filters in a hydrogen purifying tank. Tank was purged with nitrogen during cleaning. One worker leaned over a manway opening in the upper portion of the tank. He was found unconscious and later died. Case Study: Failure to Recognize Asphyxiation Hazards Near Confined Spaces :  Case Study: Failure to Recognize Asphyxiation Hazards Near Confined Spaces An operator was conducting a flammable gas test on a line connected to a flare in order to issue a hot work permit. The operator issued a permit that required an air-supplied respirator. Two contractors wore respirators to remove a valve, but the operator did not. Nitrogen inadvertently entered the flare and the operator lost consciousness. Case Study: Inadequate Monitoring of Atmosphere :  Case Study: Inadequate Monitoring of Atmosphere A tank car at a refinery contained white mineral oil, and an employee started cleaning it. The mineral oil was offloaded by injecting nitrogen gas into the car. The nitrogen was still present when the employee started to clean the car and he was asphyxiated. Case Study: Corrupt Breathing Air Supply :  Case Study: Corrupt Breathing Air Supply Two contractors were abrasive blasting tubes inside a boiler. They wore supplied-air respirators connected to compressed air cylinders. After the workers failed to respond to an air horn, they were found unconscious. Follow-up testing of the air supply – which had been manufactured by mixing oxygen and nitrogen - found that it contained less than 5% oxygen. Case Study: Mix-Up Nitrogen and Air, and Improper Rescue :  Case Study: Mix-Up Nitrogen and Air, and Improper Rescue The atmosphere inside a coated tank was tested and ventilated the day before work was to be performed inside. A contractor entered the tank to clean it the next day and collapsed. Two plant employees attempted rescue and were overcome. All three workers died. The tank had mistakenly been ventilated with nitrogen instead of compressed air. Case Study: Mix-up Nitrogen and Air:  Case Study: Mix-up Nitrogen and Air A contract employee planned to use a hammer powered by air to chip residue from a furnace in an aluminum foundry. He wore an airline respirator. Two compressed gas lines were available, one was labeled “natural gas” and one was labeled “air”. Once the respirator was in place, the employee was asphyxiated. The “air” line actually contained pure nitrogen. Case Study: Mix-up Breathing Air Supply in a Medical Facility :  Case Study: Mix-up Breathing Air Supply in a Medical Facility A supplier mistakenly delivered a cylinder of nitrogen during a delivery of oxygen cylinders. The nursing home employee mistakenly accepted the nitrogen tank. The cylinder was labeled with a nitrogen label partially covering an oxygen label. Case Study: Mix-Up Breathing Air Supply in a Medical Facility (cont’d):  Case Study: Mix-Up Breathing Air Supply in a Medical Facility (cont’d) The tank had nitrogen-compatible fittings. A maintenance employee removed the fittings from an empty oxygen cylinder and used it as an adapter to connect the nitrogen tank to the oxygen system. Four patients died and six were injured. Good Practices for Safe Handling of Nitrogen:  Good Practices for Safe Handling of Nitrogen Implement warning systems and continuous atmospheric monitoring of enclosures Continuously monitor for oxygen-deficient, toxic, or explosive atmospheres. Employ warning systems including flashing lights, alarms, and auto-locking entryways. Use personnel monitors to indicate low oxygen concentrations. Remember that the atmosphere can change over time. Good Practices for Safe Handling of Nitrogen:  Good Practices for Safe Handling of Nitrogen Ensure ventilation with fresh-air in confined and enclosed areas. Maintain continuous forced draft ventilation with fresh air before job begins and through completion. Ensure that ventilation systems are properly designed, evaluated, and maintained. Use warning systems to alert personnel if the system fails. Good Practices for Safe Handling of Nitrogen:  Good Practices for Safe Handling of Nitrogen Implement a system for the safe retrieval and rescue of workers Employees in confined spaces should wear equipment to facilitate retrieval, such as a body harness, anklets, or wristlets, and a lifeline. Standby personnel must be present at all times and have constant communication with personnel inside. Personnel should not attempt rescue unless they are properly trained and equipped. Good Practices for Safe Handling of Nitrogen:  Good Practices for Safe Handling of Nitrogen Ensure the uninterrupted flow and integrity of breathing air Take steps to ensure that supplied air is not interrupted. Steps include having alternate sources of power for air compressors, inspecting and replacing air hoses, and restricting traffic in areas with supply hoses. Carry escape packs. Ensure the composition of supplied breathing air is correct. Continuously monitor the air supply. Good Practices for Safe Handling of Nitrogen:  Good Practices for Safe Handling of Nitrogen Prevent inadvertent mix-up of nitrogen and breathing air Ensure that personnel understand the reason for specific unique fittings on cylinders of different compressed gases. Do not fabricate “adapters” to defeat their purpose. Ensure that cylinders are clearly labeled. Use color coding to identify systems. Good Practices for Safe Handling of Nitrogen:  Good Practices for Safe Handling of Nitrogen Develop and implement training programs for employees and contract personnel, including information on: Proper use of ventilation, retrieval, air monitoring, and air supply systems. Safe practices for confined space entry and rescue. Precautions to take when working around confined areas. Dangers of nitrogen enriched atmosphere and preventing mix-ups between breathing air and nitrogen. Implementing good hazard communication. More Information:  More Information A safety bulletin and 1-page brochure on the hazards of nitrogen asphyxiation, as well as this presentation, are available from the US Chemical Safety and Hazard Investigation Board. www.csb.gov (202)261-7600

Related presentations


Other presentations created by Columbia

Electrical motors
14. 11. 2007
0 views

Electrical motors

Plant Adaptations
23. 11. 2007
0 views

Plant Adaptations

Davis powerpoint
03. 10. 2007
0 views

Davis powerpoint

8 1 intro unix
29. 11. 2007
0 views

8 1 intro unix

model
07. 12. 2007
0 views

model

Coparmex Laboral Yanis Raptis
11. 12. 2007
0 views

Coparmex Laboral Yanis Raptis

moodys 1
26. 10. 2007
0 views

moodys 1

Careers English
05. 11. 2007
0 views

Careers English

Ford Carter 1975 1980
07. 11. 2007
0 views

Ford Carter 1975 1980

Class10
16. 11. 2007
0 views

Class10

Susantha Bangkok Bioethics
21. 11. 2007
0 views

Susantha Bangkok Bioethics

rciabc en
21. 11. 2007
0 views

rciabc en

SMMGEuler
30. 12. 2007
0 views

SMMGEuler

mod18 1
01. 01. 2008
0 views

mod18 1

RICGPSlideshow
03. 01. 2008
0 views

RICGPSlideshow

Space Wortzel
03. 01. 2008
0 views

Space Wortzel

CTSAs Today Part 3 Wall
04. 01. 2008
0 views

CTSAs Today Part 3 Wall

Nano Paris Oct2006 a5
07. 01. 2008
0 views

Nano Paris Oct2006 a5

vote Verification Sherman GWU
07. 01. 2008
0 views

vote Verification Sherman GWU

pocketcheffmkt
12. 12. 2007
0 views

pocketcheffmkt

ABSLec5
27. 09. 2007
0 views

ABSLec5

Rain Drops
03. 10. 2007
0 views

Rain Drops

04 Livestock Contributions
26. 11. 2007
0 views

04 Livestock Contributions

exor sigcomm
23. 12. 2007
0 views

exor sigcomm

Ici
20. 02. 2008
0 views

Ici

Family and Social Change
24. 02. 2008
0 views

Family and Social Change

InventorsWorkshop042 006
27. 02. 2008
0 views

InventorsWorkshop042 006

Lewis ISDS 2007stp
27. 03. 2008
0 views

Lewis ISDS 2007stp

Neu259 2006 2 photon
20. 11. 2007
0 views

Neu259 2006 2 photon

ASI Presentation
28. 11. 2007
0 views

ASI Presentation

MonetaryPolicyInChina
13. 04. 2008
0 views

MonetaryPolicyInChina

Team Tracer Presentation
14. 11. 2007
0 views

Team Tracer Presentation

NISL History current2
30. 10. 2007
0 views

NISL History current2

Hewitt
02. 10. 2007
0 views

Hewitt

Schmidt
08. 11. 2007
0 views

Schmidt

marineFallOffDuty
06. 11. 2007
0 views

marineFallOffDuty

muzi
29. 10. 2007
0 views

muzi

patty abramson russian
01. 10. 2007
0 views

patty abramson russian

tufts web
19. 11. 2007
0 views

tufts web

WkshpPres
26. 11. 2007
0 views

WkshpPres

thetis
31. 10. 2007
0 views

thetis

2 06 dela croce
05. 11. 2007
0 views

2 06 dela croce

RenaissanceArt
31. 10. 2007
0 views

RenaissanceArt

Gautam Handout
28. 12. 2007
0 views

Gautam Handout

WillgerodtAllRoads
01. 11. 2007
0 views

WillgerodtAllRoads

Planning Change 5C2
01. 12. 2007
0 views

Planning Change 5C2

Moving with EUROUSA
06. 11. 2007
0 views

Moving with EUROUSA