OSHA Flammables 1

Information about OSHA Flammables 1

Published on January 18, 2008

Author: Teresa1

Source: authorstream.com

Content

Flammable and Combustible Liquids:  Flammable and Combustible Liquids Introduction:  Introduction The two primary hazards associated with flammable and combustible liquids are explosion and fire Safe handling and storage of flammable liquids requires the use of approved equipment and practices per OSHA standards Flash Point:  Flash Point Flash point means the minimum temperature at which a liquid gives off enough vapor to form an ignitable mixture In general, the lower the flash point, the greater the hazard Flammable liquids have flash points below 100oF, and are more dangerous than combustible liquids, since they may be ignited at room temperature Combustible liquids have flash points at or above 100oF Although combustible liquids have higher flash points than flammable liquids, they can pose serious fire and/or explosion hazards when heated Classes of Flammable and Combustible Liquids:  Classes of Flammable and Combustible Liquids IIIA II IC IA IB 200 140 100 73 Flash Point (oF) 100 Boiling Point (oF) Combustible (FP > 100oF) Flammable (FP < 100oF) Classes of Some Flammable Liquids:  Classes of Some Flammable Liquids CLASS IA CLASS IB CLASS IC Common Name Flash Point (oF) Ethyl Ether -49 Gasoline -45 Methyl Ethyl Ketone 21 Toluene 40 Xylene 81-115 Turpentine 95 Program Components:  Program Components Control of ignition sources Proper storage Fire control Safe handling A good plan for safe use of flammable and combustible liquids contains at least these components: Sources of Ignition:  Sources of Ignition Open flames Smoking Static electricity Cutting and welding Hot surfaces Electrical and mechanical sparks Lightning Must take adequate precautions to prevent ignition of flammable vapors. Some sources of ignition include: Static Electricity:  Static Electricity Generated when a fluid flows through a pipe or from an opening into a tank Main hazards are fire and explosion from sparks containing enough energy to ignite flammable vapors Bonding or grounding of flammable liquid containers is necessary to prevent static electricity from causing a spark Bonding:  Bonding Physically connect two conductive objects together with a bond wire to eliminate a difference in static charge potential between them Must provide a bond wire between containers during flammable liquid filling operations, unless a metallic path between them is otherwise present Grounding:  Grounding Eliminates a difference in static charge potential between conductive objects and ground Although bonding will eliminate a difference in potential between objects, it will not eliminate a difference in potential between these objects and earth unless one of the objects is connected to earth with a ground wire Ventilation:  Ventilation Always provide adequate ventilation to reduce the potential for ignition of flammable vapors. Storage Fundamentals:  Storage Fundamentals Identify incompatible chemicals – check the Material Safety Data Sheet Isolate and separate incompatible materials Isolate by storing in another area or room Degree of isolation depends on quantities, chemical properties and packaging Separate by storing in same area or room, but apart from each other Storage of Flammable and Combustible Liquids:  Storage of Flammable and Combustible Liquids Storage must not limit the use of exits, stairways, or areas normally used for the safe egress of people In office occupancies: Storage prohibited except that which is required for maintenance and operation of equipment Storage must be in: closed metal containers inside a storage cabinet, or safety cans, or an inside storage room Inside storage room Safety Cans for Storage and Transfer:  Safety Cans for Storage and Transfer Approved container of not more than 5 gallons capacity Spring-closing lid and spout cover Safely relieves internal pressure when exposed to fire Flame Arrester Screen:  Flame Arrester Screen Prevents fire flashback into can contents Double wire-mesh construction Large surface area provides rapid dissipation of heat from fire so that vapor temperature inside can remains below ignition point Storage Cabinets:  Storage Cabinets Not more than 60 gal of Class I and/or Class II liquids, or not more than 120 gal of Class III liquids permitted in a cabinet Must be conspicuously labeled, “Flammable - Keep Fire Away” Doors on metal cabinets must have a three-point lock (top, side, and bottom), and the door sill must be raised at least 2 inches above the bottom of the cabinet Fire Control:  Fire Control Suitable fire control devices, such as small hose or portable fire extinguishers must be available where flammable or combustible liquids are stored Open flames and smoking must not be permitted in these storage areas Materials which react with water must not be stored in the same room with flammable or combustible liquids Transferring Flammable Liquids:  Transferring Flammable Liquids Through a closed piping system From safety cans By gravity through an approved self-closing safety faucet By means of a safety pump Since there is a sizeable risk whenever flammable liquids are handled, OSHA allows only four methods for transferring these materials: Self-Closing Safety Faucet:  Self-Closing Safety Faucet Bonding wire between drum and container Grounding wire between drum and ground Safety vent in drum Safety Pump:  Safety Pump Faster and safer than using a faucet Spills less likely No separate safety vents in drum required Installed directly in drum bung opening Some pump hoses have integral bonding wires Waste and Residue:  Waste and Residue Waste drum with disposal funnel Safety disposal can Oily-waste can (self-closing lid) Combustible waste and residue must be kept to a minimum, stored in covered metal receptacles and disposed of daily. Safe Handling Fundamentals:  Safe Handling Fundamentals Carefully read the manufacturer’s label on the flammable liquid container before storing or using it Practice good housekeeping in flammable liquid storage areas Clean up spills immediately, then place the cleanup rags in a covered metal container Only use approved metal safety containers or original manufacturer’s container to store flammable liquids Keep the containers closed when not in use and store away from exits or passageways Use flammable liquids only where there is plenty of ventilation Keep flammable liquids away from ignition sources such as open flames, sparks, smoking, cutting, welding, etc. Summary:  Summary The two primary hazards associated with flammable and combustible liquids are explosion and fire Safe handling and storage of flammable liquids requires the use of approved equipment and practices per OSHA standards An excellent reference on this topic is National Fire Protection Association Standard No. 30, Flammable and Combustible Liquids Code

Related presentations


Other presentations created by Teresa1

cairine macdonald fmi5
16. 04. 2008
0 views

cairine macdonald fmi5

Renewable Energy LCHS
23. 01. 2008
0 views

Renewable Energy LCHS

sampling
30. 01. 2008
0 views

sampling

reduceusecycle
09. 01. 2008
0 views

reduceusecycle

aaquilts
10. 01. 2008
0 views

aaquilts

volkman
12. 01. 2008
0 views

volkman

berlin nightlife
15. 01. 2008
0 views

berlin nightlife

rec10induction
16. 01. 2008
0 views

rec10induction

FIRO B Lecture
17. 01. 2008
0 views

FIRO B Lecture

AAPC Training Faith Partners
13. 01. 2008
0 views

AAPC Training Faith Partners

rules of origin english
22. 01. 2008
0 views

rules of origin english

FinalP
22. 01. 2008
0 views

FinalP

Alexander Graham Bell
24. 01. 2008
0 views

Alexander Graham Bell

Life Ch14 Animal Behavior
04. 02. 2008
0 views

Life Ch14 Animal Behavior

VOIP pres
04. 02. 2008
0 views

VOIP pres

LA Dept WLF
08. 01. 2008
0 views

LA Dept WLF

CPCB LK
12. 02. 2008
0 views

CPCB LK

dlove
17. 01. 2008
0 views

dlove

Sparks
19. 01. 2008
0 views

Sparks

FDI ENGLISH
29. 01. 2008
0 views

FDI ENGLISH

mt qbs
20. 02. 2008
0 views

mt qbs

11940 upload 00001
15. 01. 2008
0 views

11940 upload 00001

Hobart2 SIDS Afternoon
29. 02. 2008
0 views

Hobart2 SIDS Afternoon

photo presentation
03. 03. 2008
0 views

photo presentation

Rotary YE Training
14. 03. 2008
0 views

Rotary YE Training

Lecture4a
15. 03. 2008
0 views

Lecture4a

sym12 36j
16. 03. 2008
0 views

sym12 36j

euro disney final
19. 03. 2008
0 views

euro disney final

Central and Eastern Africa
02. 04. 2008
0 views

Central and Eastern Africa

vaidya
08. 04. 2008
0 views

vaidya

Found of Rec pres
17. 04. 2008
0 views

Found of Rec pres

download399
09. 01. 2008
0 views

download399

20071127120480
11. 01. 2008
0 views

20071127120480

32 charles
18. 04. 2008
0 views

32 charles

HMICPresentationInFr ance
21. 04. 2008
0 views

HMICPresentationInFr ance

1 Peter Lesson 14 Final
22. 04. 2008
0 views

1 Peter Lesson 14 Final

Demens
06. 02. 2008
0 views

Demens

ICN DTF Dec 2007 Darren Hill
24. 04. 2008
0 views

ICN DTF Dec 2007 Darren Hill

foregrounding no anim
13. 01. 2008
0 views

foregrounding no anim

annchppt
17. 01. 2008
0 views

annchppt

OverviewIntlTrade
07. 05. 2008
0 views

OverviewIntlTrade

Intro to Multilateral Agencies
08. 05. 2008
0 views

Intro to Multilateral Agencies

ISSP 2007
22. 01. 2008
0 views

ISSP 2007

reading listening
30. 04. 2008
0 views

reading listening

structureslide
02. 05. 2008
0 views

structureslide

No Strings
02. 05. 2008
0 views

No Strings

26b theoriginoflife
28. 01. 2008
0 views

26b theoriginoflife

dyn supply chains
28. 01. 2008
0 views

dyn supply chains

Woodcuts
05. 02. 2008
0 views

Woodcuts

kolesnik
14. 02. 2008
0 views

kolesnik

Using CAS with Acegi
30. 01. 2008
0 views

Using CAS with Acegi

3hc241jto8twxns
12. 02. 2008
0 views

3hc241jto8twxns

ICSB2002 Section 1 Slides
03. 03. 2008
0 views

ICSB2002 Section 1 Slides

Andy Barraclough presentation
18. 02. 2008
0 views

Andy Barraclough presentation

June2003
15. 04. 2008
0 views

June2003

collq01
25. 02. 2008
0 views

collq01

LBL CEC Presentation 2005 03 16
23. 01. 2008
0 views

LBL CEC Presentation 2005 03 16

Mt Rainier Slide Show
05. 02. 2008
0 views

Mt Rainier Slide Show

Minow Privacy Libraries
24. 03. 2008
0 views

Minow Privacy Libraries