TireFBCpowerpoint

Information about TireFBCpowerpoint

Published on February 12, 2008

Author: Reginaldo

Source: authorstream.com

Content

Energy Justice Network …helping communities protect themselves from polluting energy and waste technologies :  Energy Justice Network …helping communities protect themselves from polluting energy and waste technologies Tire Pile Problems:  Tire Pile Problems Tires cause health problems (mosquitoes) Can catch fire Expensive to get rid of Tire Derived Fuel – US EPA:  Tire Derived Fuel – US EPA General Information In 2003: 130 million scrap tires used as fuel (45% of amount generated) Shredded or whole tires used Claimed Advantages Tires produce the same amount of energy as oil and 25% more energy than coal The ash residues from TDF may contain a lower heavy metals content than some coals. Results in lower NOx emissions when compared to many U.S. coals, particularly the high-sulfur coals. EPA The Agency supports the responsible use of tires in Portland cement kilns and other industrial facilities Tire Incineration in U.S.:  Tire Incineration in U.S. 52% of U.S. scrap tires are burned 2005 US Scrap Tire Market Summary (millions of tires):  2005 US Scrap Tire Market Summary (millions of tires) Most tire incineration is done in cement kilns and paper mills These are also very polluting and have been fought by community groups Alternatives to Burning Tires:  Alternatives to Burning Tires Source Reduction Toxics Use Reduction Reuse (Retreading) Recycling Devulcanization Rubberized Asphalt Concrete Monofills Dedicated Tire Incinerators:  Dedicated Tire Incinerators Modesto Energy LP – Westley, CA Giant tire pile fire in 1999, closing plant Exeter Energy LP – Sterling, CT Opened in 1991 Its ash is considered hazardous waste due to high levels of toxic metals; ash was improperly sold as fertilizer in Washington state in the mid-1990s Geneva Energy, LLC – Ford Heights, IL Opened in 1996 fire on the conveyor feeding the boiler shut it down; reopened in recent years Heartland Energy and Recycling, LLC – Preston, MN Never built Defeated by community opposition in 2005 Slide8:  Majority owned by Caletta Renewable Energy of Boston, MA Plans to burn 800 tons of shredded tires per day Would use a “fluidized bed” boiler Expects to produce 70 megawatts of electricity Company has NO experience with building, owning or operating tire incinerators or any power plant or waste facility Erie Renewable Energy, LLC Slide9:  No state laws in Pennsylvania or neighboring states qualify energy produced from burning tires as renewable or “alternative” energy No environmental organizations consider tire incineration renewable Renewable energy certification programs do not, either The proposed federal renewable energy law also doesn’t. Tires are produced from fossil fuels and other non-renewable resources (like zinc and other metals) Tire Burning is NOT Renewable Slide10:  ERE says they won’t have stockpiles of tires because they’ll chip the tires as soon as they come in (mostly via rail) Some tires will have to be piled while waiting for the shredder Chipped/shredded tires will still be stockpiled on-site, in a building Shredded tires have a higher surface area with more air exposure and would catch fire more quickly. Tire Pile Fires Slide11:  Tire incinerator is near land that had been used as a tire dump for years. The pile was struck by lightning Sept. 22, touching off a fire that burned for a month and consumed nearly 5 million of the 7 million tires that had been stored there. Westley, CA Tire Fire Slide12:  Westley, CA Tire Fire Slide13:  Fluidized Bed Combustors FBC boiler technology over 30 years old Can be used to burn a wide range of fuels, including very poor fuels like waste coal Started to be used to burn waste coal in late 1980s Some fluidized bed waste coal burners have also been used to burn tires Slide14:  Fluidized bed combustors are one of several types of incinerators Patent claims, environmental agencies, scientific journals and industry agree The industry avoids the term “incinerator” because people recognize it as the polluting technology that it is Burning = combustion = incineration It’s not appropriate to call this “tires-to-energy” or simply a “chemical process” It is an Incinerator! Slide15:  Large volumes of limestone are added to fluidized bed burners to control sulfur emissions For waste coal burning fluidized bed burners, 85 tons of highly toxic ash are created for every 100 tons of waste coal burned The Exeter Energy tire incinerator in Sterling, CT has been considered a “Large Quantity Generator” of hazardous waste Incinerators are “Waste-to-Toxic Ash and Toxic Air Emissions Machines” Chemical Composition of Tires:  Chemical Composition of Tires Typical types of materials used to manufacture tires: Synthetic Rubber Natural Rubber Sulfur and sulfur compounds Silica Phenolic resin Oil: aromatic, naphthenic, paraffinic Fabric: Polyester, Nylon, Etc. Petroleum waxes Pigments: zinc oxide, titanium dioxide, etc. Carbon black Fatty acids Inert materials Steel Wire Source: U.S. Rubber Manufacturers Association / Scrap Tire Management Council Chemical Composition of Tires:  Chemical Composition of Tires Representative Analysis of TDF Produced By WRI (Source: TDF Produced From Scrap Tires with 96+% Wire Removed) Source: U.S. Rubber Manufacturers Association / Scrap Tire Management Council Chemical Composition of Tire Ash:  Chemical Composition of Tire Ash Preliminary Results Of Slag (Bottom Ash) Analysis Source: U.S. Rubber Manufacturers Association / Scrap Tire Management Council Chemical Composition of Tire Ash:  Chemical Composition of Tire Ash Note: These results are from incineration of 100% tire fuel. Sources: Radian Corporation, Results From Sampling and Analysis of Wastes From the Gummi Mayer Tire Incinerator, May 1985. Source: U.S. Rubber Manufacturers Association / Scrap Tire Management Council Tire Derived Fuel Emissions:  Tire Derived Fuel Emissions Data on emissions from tire burning varies Some studies compare a mixture of tires and coal to 100% coal; others compare to other mixtures of fuels Chemical composition of coal can vary by coal type and region Data is from cement kilns, paper mills or other industrial boilers Operating conditions may vary Tire Derived Fuel Emissions:  Tire Derived Fuel Emissions Common trends in comparing TDF/coal mixture to 100% coal Chlorine in Tires:  Chlorine in Tires Add Chlorine to tires Aromatic extender oils “Salt-bath" vulcanization process Halogenated butyl rubber liners California study: Tires have 2-5 times the chlorine level of western coal EPA survey: chlorine levels in tires 2% higher than the national average for bituminous coal Dioxin Facts:  Dioxin Facts Dioxins and furans are the most toxic chemicals known to science. They are highly toxic even in miniscule amounts. Dioxins cause infertility, learning disabilities, endometriosis, birth defects, sexual reproductive disorders, damage to the immune system, cancer and more. 93% of dioxin exposure is from eating meat and dairy products. Exposure to Dioxins:  Exposure to Dioxins How to make dioxin:  How to make dioxin Dioxins are created by burning hydrocarbons (fossil fuels, tires, hazardous wastes) with chlorine (present in coal, tires and some hazardous wastes) in the presence of oxygen. Dioxin emissions increase when: More chlorine is in the fuel/waste stream (tires have more chlorine than coal) Certain metal catalysts are present (tires have iron and zinc) The gases stay in a low temperature range (200-450o C) Dioxin Emissions from Tire Burning:  Dioxin Emissions from Tire Burning Slide27:  Creating Cancer Polycyclic aromatic hydrocarbons (PAHs): group of over 100 different chemicals that are formed as byproducts of combustion Most PAHs are known to cause cancer in animals and are suspected to cause cancer, birth defects and a wide variety of other health problems in humans. Fluidized bed combustors form PAH more than normal coal burners due to: use of limestone injection low oxygen levels lower combustion temperature range low-rank coal higher sulfur levels in fuel higher chlorine levels in fuel Benzo(a)pyrene Mercury (Hg):  Mercury (Hg) Comes in three forms: methylmercury, elemental mercury, and other mercury compounds. The most common exposure is to methylmercury, which leads to impair neurological development and, in severe cases, peripheral vision impairment, sensation disturbances, lack of coordination, speech impairment, hearing impairment, and muscle weakness. Some studies show an increase in mercury emissions from adding tires to a fuel blend. Ground-Level Ozone, a.k.a. Smog:  Ground-Level Ozone, a.k.a. Smog By deflecting UV radiation, ozone is beneficial in the upper atmosphere, but at ground-level it is highly toxic. The EPA’s Clean Air Scientific Advisory Committee has urged that the ozone standard be more protective of public health. Ozone (“O3”) is not emitted directly as air pollution. It is created by chemical reactions between oxides of nitrogen (NOx) and volatile organic compounds (VOC) in the presence of sunlight. Numerous scientific studies have linked ground-level ozone exposure to a variety of problems, including: lung irritation that can cause inflammation much like a sunburn; wheezing, coughing, pain when taking a deep breathe, and breathing difficulties during exercise or outdoor activities; permanent lung damage to those with repeated exposure to ozone pollution; and aggravated asthma, reduced lung capacity, and increased susceptibility to respiratory illnesses like pneumonia and bronchitis. Sulfur Dioxide (SO2):  Sulfur Dioxide (SO2) SOx gases are formed when fuel containing sulfur, such as coal and oil, is burned, and when gasoline is extracted from oil, or metals are extracted from ore. Peak levels of SO2 in the air can cause temporary breathing difficulty for people with asthma who are active outdoors. Longer-term exposures to high levels of SO2 gas and particles cause respiratory illness and aggravate existing heart disease. Precursor to fine particulates, causes acid rain, reduces visibility, damages crops and ecosystems, and damages historic monuments. Particulate Matter (PM), a.k.a. Soot:  Particulate Matter (PM), a.k.a. Soot Grouped by the EPA into two categories: “Inhalable Course Particles”, basically dust “Fine Particles”, smallest particles, found in smoke and haze Fine particles generate the most concern and have a range of health effects: increased respiratory symptoms, such as irritation of the airways, coughing, or difficulty breathing, for example; decreased lung function; aggravated asthma; development of chronic bronchitis; irregular heartbeat; nonfatal heart attacks; and premature death in people with heart or lung disease. Volatile Organic Compounds (VOCs):  Volatile Organic Compounds (VOCs) VOCs are a family of chemicals which have varying short- and long-term adverse health effects. Health effects of exposure to VOCs include eye, nose, and throat irritation; headaches, loss of coordination, nausea; damage to liver, kidney, and central nervous system. Some organics can cause cancer in animals; some are suspected or known to cause cancer in humans. Nitrogen Oxides (NOx):  Nitrogen Oxides (NOx) Nitrogen oxides is the generic term for a group of highly reactive gases, all of which contain nitrogen and oxygen in varying amounts. Nitrogen oxides form when fuel is burned at high temperatures, as in a combustion process. The primary manmade sources of NOx are motor vehicles, electric utilities, and other industrial, commercial, and residential sources that burn fuels. Problems associated with NOx: Precursor to ground-level ozone; Causes acid rain; Precursor to particulates; Deteriorates water quality (eutrophication); Impairs visibility; and Leads to formation of toxic chemicals: In the air, NOx reacts readily with common organic chemicals and even ozone, to form a wide variety of toxic products. Slide34:  Global Warming / Climate Change Pennsylvania already emits 1% of the entire world’s greenhouse gas emissions. “N2O has a Global Warming Potential 296 times that of CO2.” “N2O is emitted from fluidized bed coal combustion… N2O emission from the FBC is equivalent to… an increase of about 15% in CO2 emissions for an FBC boiler” -National Coal Council, May 2003 Test Burns are Unreliable:  Test Burns are Unreliable Emissions estimates and regulatory enforcement usually based on infrequent testing under optimal conditions Tests don’t reflect startup, shutdown and upset conditions Tests are usually done with careful attention paid to temperature, air flow and other operating conditions May take multiple samples until one passes Tests are very infrequent Continuous Emissions Monitors:  Continuous Emissions Monitors Only generally used for sulfur oxides (SOx), nitrogen oxides (NOx), oxygen (O2) and carbon monoxide (CO) Technology now exists to continuously monitor: Ammonia (NH4) Carbon Dioxide (CO2) Hydrogen Sulfide (H2S) Acid Gases: Sulfuric Acid (H2SO4) Hydrofluoric Acid (HF) Hydrochloric Acid (HCl) Products of Incomplete Combustion (PICs): Dioxins & Furans Polycyclic Aromatic Hydrocarbons (PAHs) Volatile Organic Compounds (VOCs) Metals: Antimony (Sb) Arsenic (As) Barium (Ba) Cadmium (Cd) Chromium (Cr) Lead (Pb) Manganese (Mn) Mercury (Hg) Silver (Ag) Nickel (Ni) Zinc (Zn) …and more Slide37:  FOR MORE INFO: Keep Erie’s Environment Protected www.stopburningtires.com Energy Justice Network’s Tire Incineration Page www.EnergyJustice.net/tires/ ActionPA www.ActionPA.org PA’s “Alternative” Energy Law www.ActionPA.org/cleanenergy/ Energy Justice Network …helping communities protect themselves from polluting energy and waste technologies :  Energy Justice Network …helping communities protect themselves from polluting energy and waste technologies

Related presentations


Other presentations created by Reginaldo

fall construction
08. 01. 2008
0 views

fall construction

Maori Culture
10. 01. 2008
0 views

Maori Culture

3rdconf tonetti
11. 01. 2008
0 views

3rdconf tonetti

GoodFaith
13. 01. 2008
0 views

GoodFaith

2004 u apresentacao
13. 01. 2008
0 views

2004 u apresentacao

MetaRx
14. 01. 2008
0 views

MetaRx

pp4
15. 01. 2008
0 views

pp4

BLAST
16. 01. 2008
0 views

BLAST

Quasi Newton
16. 01. 2008
0 views

Quasi Newton

Cultural Competence
17. 01. 2008
0 views

Cultural Competence

miracles gcse
17. 01. 2008
0 views

miracles gcse

AC Grad Presentation
18. 01. 2008
0 views

AC Grad Presentation

The Colonial Period
19. 01. 2008
0 views

The Colonial Period

farag
22. 01. 2008
0 views

farag

Georgia MRSA
23. 01. 2008
0 views

Georgia MRSA

khan
24. 01. 2008
0 views

khan

kelly
05. 02. 2008
0 views

kelly

Backyard Biology
25. 01. 2008
0 views

Backyard Biology

statia pptreview1
28. 01. 2008
0 views

statia pptreview1

ER to REL
29. 01. 2008
0 views

ER to REL

Doctor Faustus
29. 01. 2008
0 views

Doctor Faustus

Event Planning Record 9
06. 02. 2008
0 views

Event Planning Record 9

ciforp
07. 02. 2008
0 views

ciforp

Yuan and Ming Dynasties
07. 02. 2008
0 views

Yuan and Ming Dynasties

MissionPossible
13. 02. 2008
0 views

MissionPossible

20050517 TCBACMeeting Process
14. 02. 2008
0 views

20050517 TCBACMeeting Process

SpiralDynamics IPGA
18. 02. 2008
0 views

SpiralDynamics IPGA

cs554 lect05
11. 01. 2008
0 views

cs554 lect05

NIHPCS1002f
24. 01. 2008
0 views

NIHPCS1002f

mandarin 103007
11. 03. 2008
0 views

mandarin 103007

AAMAS07 Invitation
14. 03. 2008
0 views

AAMAS07 Invitation

lahey9e 08
08. 02. 2008
0 views

lahey9e 08

2006 12 01 Roman
28. 03. 2008
0 views

2006 12 01 Roman

M6
09. 01. 2008
0 views

M6

Hurd IRAC
12. 01. 2008
0 views

Hurd IRAC

Applications January 2007v2
10. 04. 2008
0 views

Applications January 2007v2

maxine brown
16. 04. 2008
0 views

maxine brown

aegean
08. 03. 2008
0 views

aegean

200571816522254
18. 04. 2008
0 views

200571816522254

Gross Domestic Product vs
21. 04. 2008
0 views

Gross Domestic Product vs

2000 annual results analyst
22. 04. 2008
0 views

2000 annual results analyst

CERTUnit8
24. 04. 2008
0 views

CERTUnit8

Chap05
07. 05. 2008
0 views

Chap05

PPT RobertScollay
08. 05. 2008
0 views

PPT RobertScollay

Overview2006
05. 02. 2008
0 views

Overview2006

caring
30. 04. 2008
0 views

caring

8 09 15
02. 05. 2008
0 views

8 09 15

Abilene Metadata 2 20070919
03. 03. 2008
0 views

Abilene Metadata 2 20070919

491158BECB
02. 05. 2008
0 views

491158BECB

LT1053N 01 2007
04. 02. 2008
0 views

LT1053N 01 2007

Washingtons Presidency
22. 01. 2008
0 views

Washingtons Presidency

1 20080121100630
14. 04. 2008
0 views

1 20080121100630

mccrory
12. 03. 2008
0 views

mccrory

EHS Tech Update1 6 23 20041
09. 01. 2008
0 views

EHS Tech Update1 6 23 20041

FrancoisViruly
04. 02. 2008
0 views

FrancoisViruly

Hamburgpipe
14. 01. 2008
0 views

Hamburgpipe

Sercel
17. 01. 2008
0 views

Sercel

fg alt off learn sept 06
15. 01. 2008
0 views

fg alt off learn sept 06

1 800 MAR TIAN
24. 01. 2008
0 views

1 800 MAR TIAN

bergmann erf 1999
29. 02. 2008
0 views

bergmann erf 1999

YLemel Brno
07. 02. 2008
0 views

YLemel Brno

A Lamond Triton
11. 01. 2008
0 views

A Lamond Triton

Sarcoidosis 3
11. 02. 2008
0 views

Sarcoidosis 3

Bilanz Mediakomm Kraft
31. 01. 2008
0 views

Bilanz Mediakomm Kraft

BJA IED Mod1 IntrotoIED
11. 01. 2008
0 views

BJA IED Mod1 IntrotoIED

Vols of Yr Event 2006 26 Apr
04. 02. 2008
0 views

Vols of Yr Event 2006 26 Apr