vollhardt lecc2005

Information about vollhardt lecc2005

Published on October 17, 2007

Author: CoolDude26

Source: authorstream.com

Content

Production of the LHCb Silicon Tracker Readout Electronics :  Production of the LHCb Silicon Tracker Readout Electronics Outline:  Outline Overview of the Readout Electronics 1st preproduction of Digitizer Board Evaluation of performance Integration with LHCb hardware 2nd preproduction Conclusion LHCb Silicon Tracker principle:  LHCb Silicon Tracker principle Two distinct tracking systems based on silicon strip detectors, read out via the BEETLE chip TT: full acceptance angle covered upstream of magnet IT: only area of highest track densities around beampipe Beetle readout chip:  Beetle readout chip 128 channel charge integrator polyimide readout hybrid carries 3 (IT) or 4 (TT) Beetle chips for sensors of 384 (IT) or 512 (TT) strips See also: Talk of F. Lehner: Hybrid Design, Procurement and Testing for the LHCb Silicon Tracker ST Readout electronics:  ST Readout electronics Service Box Overview:  Service Box Overview Digitizer Board backplane sensor + readout hybrids Digitizer Board up to 16 hybrids/boards Control Card TTC ECS 5m copper cable Optical fibres for physics data Digitizer Board characteristics:  Digitizer Board characteristics 6 layer PCB, halogen-free, 1.6 mm thickness, symmetric stack single side mounting, no buried/blind vias smallest feature size 6 mil, smallest package 0603 5 BGA devices: 1x CS49 (0.8 mm pitch), 3-4x BGA144(1.0 mm pitch) no JTAG chain , no boundary scan differential traces have controlled impedance/length standard commercial connectors NO tuning points layout optimized for low-cost, high-yield, easy testing 2 versions: Trigger Tracker (4-chip readout), Inner Tracker (3-chip readout) 1. Preproduction run:  1. Preproduction run 17 boards produced and electrically tested in late 2004 (TT version) after assembly, all BGAs X-rayed: all solder joints ok! 2 bugfixes: wrong reference voltage for line receiver Auto-Sync FPGA: shift register one cycle (25ns) too short all boards except one immediately working: board #10 had ripped via under BGA (fixed) changes for IT version preproduction (and final production): changed VCSEL biasing added QPLL RC-network for improved jitter stability Digitizer Board:  Digitizer Board Power <5 W Only positive voltages: 2.5 V, 5.0 V Beetle signal at ADC:  Beetle signal at ADC Flat top 15 nsec wide (of 25 nsec max.) measured with 5m twisted pair cable plenty of ‘space’ to set ADC sampling point Linearity:  Linearity Sampling synchronicity I:  Sampling synchronicity I supply all 16 inputs with ‘synchronous’ testpulse: testpulse generator sourcing 16 LVDS drivers move sampling time by using TTCrx clock phase shifters (just like in experiment..) transmit data via GOL+ optical fibres to DACs and scope record pulseheight of sampled edge vs. programmed delay Sampling synchronicity II:  Sampling synchronicity II GOL VCSEL connection:  GOL VCSEL connection VCSEL forward voltage with 2.5V anode voltage results in too low GOL current driver voltage level only 2.5V and 5V available reduced to 3.3V by low-impedance divider blocked at VCSEL with 100nF||100pF Eye diagram after 100m:  Eye diagram after 100m Thanks to Paolo Ciambrone/LHCb Muon Auto-sync:  Auto-sync Beetle DataValid signal (almost) in parallel to analogue data to frame a triggered event done via shift register in Actel antifuse FPGA (small version of rad-hard AX54SX32) incl. TMR+ majority voting Results in at least one IDLE frame per event Beetle analogue output Beetle DataValid Beetle data after digitization DataValid after 200 ns delay Radiation qualification:  Radiation qualification Expected radiation levels for Service Box location for 10 years: TID 15 krad, NIEL 2E12 n/cm2 all commercial devices individually radiation qualified (TID, NIEL and SEE) with proton and neutron irradiation according to LHCb radiation policy System test: TT Digitizer Board + backplane re-tested in June 2005 with 60 MeV protons to 60 krad (PSI, Switzerland): analogue test pattern injected verification of function and performance no variations in module operation observed Full Readout test:  Full Readout test Full Readout test:  Full Readout test LHCb-style readout (except LHCb Readout Supervisor + CPU farm) Control Card:  Control Card Under development by Universidade de Santiago de Compostela Provides TTC signals and slow control interface to each Service Box and its associated frontend electronics First prototype functional (still being tested) Breaking News: IT version:  Breaking News: IT version 10 Digitizer Boards (IT version preproduction) were delivered last Wednesday initial testing confirm out-of-the-box functionality important step: re-validate eye diagram with new VCSEL bias! Next steps:  Next steps detailed testing of IT prototypes: last design verification launch production order after: production+assembly time for all boards: ca. 8-10 weeks all parts available except for VCSELs (LHCb common order placed, expected in November) ‘bird-food’ supplied by company, special components by us start setting up test bench during production: basic functionality test (go-nogo) burn-in test (catch infant mortality) Conclusion + Outlook:  Conclusion + Outlook The preseries production for both versions of the ST Digitizer Board has been completed. Bugfixes and lessons learned in the TT version were successfully included in the IT version. Required functionality was verified and system compatibility with common LHCb hardware has been shown. Preseries hardware is used to form teststands for the TT sensor module production (Zuerich) and the IT sensor production (CERN) Final qualification pending, design will be released for full production in Q4/05. SPARE SLIDES:  SPARE SLIDES Digitizer Board input stage:  Digitizer Board input stage Bandwidth: 1.6 kHz (AC-Coupling) to 170 MHz (AD8129) Amplifier output range matches ADC input range Clock tree:  Clock tree TFC distribution:  TFC distribution Impedance controlled traces for LVDS signals TTL traces only used for short (~ 2 cm) for fanning out equal trace lengths to minimize ch-ch skew Service Box: frame:  Service Box: frame Fully loaded weight: ca. 10 kg Power disipation: ca. 150 W (70 W into mixed water cooled heatsink) Service Box cooling:  Service Box cooling all linear regulators located close to each other use common copper heatsink (mixed water) to cool all at once isolate ground slug of regulator package (local ground!) used for testing: CPU water cooling system: no active cooler, but fan-blown heat-exchanger Test at full load results in 35 degC case temperature for 25 degC water (=ambient temperature) IT mounting:  IT mounting Service Boxes outside acceptance Mounted on common IT station frame ‘5m copper cables’ no not move cables from Service Box away from detector move (cable chains) TT mounting:  TT mounting Service Boxes mounted outside acceptance to magnet ‘5m copper cable’ guided in cable chains to station halves cables away from Service Box fixed in cable trays

Related presentations


Other presentations created by CoolDude26

CH8 PowerPoint Robotics
31. 12. 2007
0 views

CH8 PowerPoint Robotics

challenging behavior
17. 09. 2007
0 views

challenging behavior

ch1
17. 09. 2007
0 views

ch1

IP P mohan
19. 09. 2007
0 views

IP P mohan

RMP October 2006 Data
11. 10. 2007
0 views

RMP October 2006 Data

standing2
12. 10. 2007
0 views

standing2

lam talk
15. 10. 2007
0 views

lam talk

Escher
15. 10. 2007
0 views

Escher

2006 Radicarbon History
16. 10. 2007
0 views

2006 Radicarbon History

pre b373
17. 10. 2007
0 views

pre b373

banderas2
22. 10. 2007
0 views

banderas2

ostrichsm
17. 09. 2007
0 views

ostrichsm

209 OASIS Ostrich presentation
17. 09. 2007
0 views

209 OASIS Ostrich presentation

ssec software development
07. 10. 2007
0 views

ssec software development

dianxinyezhuanxing
12. 10. 2007
0 views

dianxinyezhuanxing

africa presentation
23. 10. 2007
0 views

africa presentation

spatial databases
23. 10. 2007
0 views

spatial databases

232nm13
29. 10. 2007
0 views

232nm13

ans321L2
17. 09. 2007
0 views

ans321L2

Plan Bleu partie2
24. 10. 2007
0 views

Plan Bleu partie2

05 galaxies
29. 08. 2007
0 views

05 galaxies

nuclearWeapons
23. 12. 2007
0 views

nuclearWeapons

ChristensenNov2
29. 08. 2007
0 views

ChristensenNov2

Unit3
03. 01. 2008
0 views

Unit3

como fazer palestra espirita
07. 01. 2008
0 views

como fazer palestra espirita

XES Architecture Vacuum v2
17. 09. 2007
0 views

XES Architecture Vacuum v2

2 tinyos
29. 10. 2007
0 views

2 tinyos

Lecture16 overheads
21. 08. 2007
0 views

Lecture16 overheads

Hip Injuries in Athletics PartI
01. 08. 2007
0 views

Hip Injuries in Athletics PartI

jsimon irvine
29. 08. 2007
0 views

jsimon irvine

GeorgeMiley LOFAR May06
29. 08. 2007
0 views

GeorgeMiley LOFAR May06

jim brady
05. 10. 2007
0 views

jim brady

automotive invitation
24. 10. 2007
0 views

automotive invitation

microscopy
15. 10. 2007
0 views

microscopy

General Psychopathology
16. 02. 2008
0 views

General Psychopathology

The Virus of Violence
20. 02. 2008
0 views

The Virus of Violence

cindy pragma grid
17. 10. 2007
0 views

cindy pragma grid

ASOCallPresentation2 006WBSD
18. 03. 2008
0 views

ASOCallPresentation2 006WBSD

China Korea Trip Info
25. 03. 2008
0 views

China Korea Trip Info

A105 021 GalI
29. 08. 2007
0 views

A105 021 GalI

widefield yan
29. 08. 2007
0 views

widefield yan

blain cosmoskyoto
29. 08. 2007
0 views

blain cosmoskyoto

Corporate Profile November 2007
27. 03. 2008
0 views

Corporate Profile November 2007

Cal Mrtg Watkins
10. 04. 2008
0 views

Cal Mrtg Watkins

pcreek
13. 04. 2008
0 views

pcreek

7 9 kraft
29. 08. 2007
0 views

7 9 kraft

neos innovation challenge short
14. 04. 2008
0 views

neos innovation challenge short

nslab diffserv 06a
16. 04. 2008
0 views

nslab diffserv 06a

podraza medicare
17. 04. 2008
0 views

podraza medicare

Capitalizing
18. 04. 2008
0 views

Capitalizing

Meyer
22. 04. 2008
0 views

Meyer

forbes manhattan presentation
28. 04. 2008
0 views

forbes manhattan presentation

cs4811 ch09 uncertainty
17. 09. 2007
0 views

cs4811 ch09 uncertainty

Managing Tough Decisions
17. 09. 2007
0 views

Managing Tough Decisions

David Ellis powerpoint
30. 04. 2008
0 views

David Ellis powerpoint

Anesthetic Machines
02. 05. 2008
0 views

Anesthetic Machines

ADSL NTT
09. 10. 2007
0 views

ADSL NTT

ABM12006
15. 10. 2007
0 views

ABM12006

Richstone Mitchell
29. 08. 2007
0 views

Richstone Mitchell

CIP TOA and Beyond 5 29 07
03. 01. 2008
0 views

CIP TOA and Beyond 5 29 07

Thomson top panic05
18. 06. 2007
0 views

Thomson top panic05

Thesis defense rev12
18. 06. 2007
0 views

Thesis defense rev12

tftge dec 02
18. 06. 2007
0 views

tftge dec 02

Temp bone trauma slides 051012
18. 06. 2007
0 views

Temp bone trauma slides 051012

tamara
18. 06. 2007
0 views

tamara

tactical euro condor06
18. 06. 2007
0 views

tactical euro condor06

Stolarz D 1603
18. 06. 2007
0 views

Stolarz D 1603

stoc04
18. 06. 2007
0 views

stoc04

stabicp slides
18. 06. 2007
0 views

stabicp slides

Sofia Sima 2 ext new
18. 06. 2007
0 views

Sofia Sima 2 ext new

slacbaryo genesis
18. 06. 2007
0 views

slacbaryo genesis

iyef project homeless connect
31. 10. 2007
0 views

iyef project homeless connect

SOFG
18. 06. 2007
0 views

SOFG

NorthStar
13. 11. 2007
0 views

NorthStar

rickwilliams
21. 08. 2007
0 views

rickwilliams

Noah s Ark
03. 10. 2007
0 views

Noah s Ark

ambertech
19. 11. 2007
0 views

ambertech

Soc RespI SOC02
17. 09. 2007
0 views

Soc RespI SOC02

Internet Protocol Addresses
15. 06. 2007
0 views

Internet Protocol Addresses

Colour Reconnection
15. 06. 2007
0 views

Colour Reconnection

Research & Development
15. 06. 2007
0 views

Research & Development

Low Frequency Gravitational Wave
15. 06. 2007
0 views

Low Frequency Gravitational Wave

vander Marel mgct2 win
29. 08. 2007
0 views

vander Marel mgct2 win

G020514 00
17. 09. 2007
0 views

G020514 00

aas calzetti
29. 08. 2007
0 views

aas calzetti

jokes riddles
17. 09. 2007
0 views

jokes riddles

vaulttutorial
19. 09. 2007
0 views

vaulttutorial

Ch90 ExtensionsToFOPC
17. 09. 2007
0 views

Ch90 ExtensionsToFOPC

Mercurio
29. 08. 2007
0 views

Mercurio

Eric Gawiser pire galclust
29. 08. 2007
0 views

Eric Gawiser pire galclust

Eric Gawiser pire galform
29. 08. 2007
0 views

Eric Gawiser pire galform

1 Dirk Van Braeckel
23. 10. 2007
0 views

1 Dirk Van Braeckel

directors roundtable 0407
02. 10. 2007
0 views

directors roundtable 0407

MWR
01. 08. 2007
0 views

MWR

01 Singleton
17. 09. 2007
0 views

01 Singleton

astro101 2000oct
15. 11. 2007
0 views

astro101 2000oct

CCAT06 Chapman
29. 08. 2007
0 views

CCAT06 Chapman

nips06 tutorial
17. 09. 2007
0 views

nips06 tutorial

90convexpo Jeff Tobe ppt
17. 09. 2007
0 views

90convexpo Jeff Tobe ppt